Ford Excursion :: Strong Smell Of Gas At The Back Of The Truck / Fuel Tank Pressurizing
On a recent long drive home through some very hot weather, I noticed a strong smell of gas at the back of the truck. Now, I've caught a whiff of gas before the trip but it was always faint. Figured it was some gas that dripped on fill up.
At a rest area, I go and look around see no leaks and finally check the fuel cap. Lots of pressure trapped. I ended up leaving the cap off the rest of the run home. Can't find a cause.
Accent LC (2000-05) :: 2001 GS Runs Rough On Full Tank / Fuel Smell In Car
I have recently purchased a 2001 Accent GS which has the 1.6L DOHC engine and have done a big road trip in it which has created a problem. When I fill the fuel tank up it runs really rough, has no power, and stalls at idle unless I keep the revs up. I can also smell petrol very strongly in the car all the time, plus it's running really rich as I can smell fuel on the exhaust and the last symptom is the loss of power down low(due to running rich).
I was on my road trip so had no tools on me and got the local mechanic of a small town to do a few basic things (change spark plugs, leads, and fuel filter) but to no avail. It runs smoothly when it gets below the full line on the fuel level gauge so I just didn't fill it up completely to get the car home but it still runs really rich and doesn't have quite as much power.
Ford Excursion :: Mounting 2nd Fuel Tank?
I am going to mount a second fuel tank on my excursion -- I have measured and build a simple cardboard model. even measurements that they have used in the past? I looked at the tanks on
[URL]
they don't have any specifically for the Excursion I am thinking that the shortbox 250/350's probably are too long for the excursion.
Ford Super Duty (1999-2016) :: 2003 F250 V10 - Fuel Smell / Gas Tank Vent Leak
New to me 2003 F250 Super Cab 6.8 V10. Great condition inside and out. 68,000 miles. Began smelling fuel (gas) a few days after driving it 250 miles from purchase location. Traced leak down to the top of the gas tank. Staining was visible around the rear vent. Applied about 5 psi to the tank and sprayed soap around until I saw bubbles coming from a hairline crack at the rear vent connection. Its where the fitting for the hose comes out of the tank.
My first choice would be to hot weld the crack. I'm not very comfortable with the idea of a heat source near a gas tank. I'm not sure, but the heat from the plastic welder might be hot enough to ignite fumes? Second option is to try some industrial 2 part epoxy (PIG) and seal it with that. Is there pressure inside the tank, and if so how much? Can try this fix with epoxy or JB Weld?
Santa Fe (CM - 2007-12) :: Fuel Smell In Cabin If Fill The Tank To Full
I have a 2007 Santa Fe. If I fill the tank to full, or close to full I will have a fuel smell in the car until the tank runs under 3/4. If I keep it under 3/4 I usally do not get the smell in the car.
The dealer could not figure it out and I still have this issue. It seems the smell is more in the front of the cabin then the rear. It just could seem that way since the smell is very strong. I have to park the car with the windows open.
There are no fuel leaks, no fuel on the ground, no drips, and the no spillage when I filled the tank.
Elantra XD (2001-06) :: Gas Smell After Filling Tank
First time I've filled the car up and getting a gas smell while driving. I checked the gas cap and it's on.
View 3 RepliesSanta FE SM (2001-06) :: Fuel Light Will Come On With Quarter Tank Of Gas
Here is my problem I own a 2006 2.7l santa fe and I will be sitting there with a quarter tank of gas I then my gas light will come on I will look and I am outta gas then it will go back to a quarter, I am noticing it more often.
View 2 RepliesElantra XD (2001-06) :: Cannot Fill Fuel Tank / Gas Overflows When Filling
I have an 04 Elantra GT. My gas gauge is showing full but the car is running out of gas. I try to fill the tank and I get the annoying click and after trying for a few, gas comes up the filler and overflow tube and makes a mess. At the same time, I was getting a P0449 code. I got an evap canister from the junkyard and that seems to have gone away.
Tried diagnosis but dropping the fuel tank to access the lines. When I jack the tank back up into position, you can hear gurgling sounds and as if the gas is coming up the fill tube. I also opened the access panel under the seat to see the pump assembly and when I removed the 8mm bolts, gas came pouring out. There was definitively gas in there. Checked the float on the pump assembly and it moved?
There is also something at the fuel neck at the top. Don't know what it is and if that could also be part of the problem.
Elantra XD (2001-06) :: Engine Stalls After Over Filling Fuel Tank
After over filling my fuel my car stalls (sometimes) on going back to idle. Not sure what to checks, check engine light is not on.
View 2 RepliesSanta FE SM (2001-06) :: Fuel Leaking From The Driver Side Of Tank
Not my Elantra, but an '05 Santa Fe 2.7 ... I have a fuel leak from the driver's side of the tank. It has continued leaking while the vehicle has been parked with about a quarter tank of gas, even after 8 hours. I can see where it is leaking from - a quarter size depression in the tank - but I think this is some sort of plastic pan, not the tank itself.
Is there is a plastic pan under the tank?
If so, does it cover just the bottom half?
If it is a plastic pan, is the tank itself plastic or metal?
If it is plastic I don't see how it could develop a leak, so is it possible for the leak to be at the top of the tank due to a fuel line problem (maybe some mysterious syphon condition)?
I searched the forum and leaking fuel tanks don't seem to be a common problem. My usual parts store doesn't even have a listing for a replacement fuel tank.
SC/SL/SW :: 2001 SL2 Not Starting And Fuel Gauge Reads Empty With More Than Half Tank Of Gas
My 01 sl2 wont start and the gauge says that the car is empty (before this problem, everything was working fine). I know that I have more than a half tank of gas, the car continuously turns over but wont start. I replaced the fuel pump and still it wont start (not to mention that the tank was more than half full at the time). I checked all the fuses and relays and everything seems fine. I am not even getting gas pumped to the filter.
View 9 RepliesSanta FE SM (2001-06) :: Loss Of Power - Jerky Acceleration With 1/4 Tank Of Fuel
We have a 2002 Sante Fe with v6 and 270,000 km on it. Just had extreme loss of power and jerky acceleration from a stop. This has happened a few times in the past year and each time with a 1/4 tank of fuel? We pulled into a gas station, filled it up and away we go like nothing was wrong?
View 4 RepliesChevrolet - 1500 :: 2001 Acts Like Running Out Of Fuel When Gas Tank Is Over Half Full
I have a 2001 Chevy Silverado with the 4.8L V-8 engine. It acts like it is running out of gas ( the gas tank is over half full). The truck has sat for about 6 months in this condition without being started here in Sacramento, CA. I then replaced the fuel filter and for a few minutes it started and the engine ran fine (without actually driving it). A few days later I started it again and it now again acts like it has fuel starvation, it will rev up briefly then act like it is running out of fuel. I know the fuel pumps are the Achilles Heel of these trucks, but before I try changing it I was wondering if there might perhaps be another problem such as the new fuel filter plugging up quickly or possibly an electrical problem. I've always heard these fuel pumps either work or they don't work, nothing in between. This problem is intermittent but big enough the truck is not driveable. Is there any way to get a good take on the problem before diving into the fuel pump replacement and hoping that solves the problem ?
View 5 RepliesSanta FE SM (2001-06) :: Smell Of Raw Fuel When Filling Up
The last 2 times I have filled up at the pump and started driving from the station there is the strong smell of raw fuel in the cabin while driving and on the highway as well even with the windows down. It slowly dissipates after driving 5 miles or so and does not occur again until the next time I fill up. What it can be?
View 1 RepliesElantra XD (2001-06) :: Gauge Showing Empty And Low Fuel Light Stays On When Tank Is Full
Ok so the fuel gauge says empty and the low fuel light stays on even though the tank is full. I'm assuming its either the gauges or the sending unit. If it is the sending unit where is it located on this car?
View 4 RepliesFord Excursion :: 2001 - Fuel Filter Housing Leaking
I could smell fuel so I popped the hood to look for a leak. On top of the filter housing cover fuel was puddled in the little nooks and crannies of the black cover and some had leaked over the side into the valley between the heads. Is this a common leak? How in the world did fuel get on top of the cover but not on the hood insulator cover?
Also, just bought this not too long ago and the po said he had just done the fuel filter service on it. The gasket seemed pretty flimsy and weak and didn't really fit the gasket surface. Although I'm used to my cummins powered trucks and they use a o-ring to seal the housing cover. 2001 excursion 7.3
Ford Excursion :: 2001 V10 - No Tach Or Fuel Reading At Startup For A Minute Or So
Occasionally when i start my Ex, there will be NO tach reading (0 RPM) and NO fuel gauge reading (E). The Temp and Oil gauges will work fine though.
After a min or so, they come to life and move normally. This happens intermittently.
2001 V10 4x4 Limited.
Santa FE SM (2001-06) :: Strong Smell Of Fuel From Under Car But No Visible Leak
I have an Oct 2001 2.7 GLS which apart from the odd ABS Tone Wheel and speed sensor issues has been uber reliable and a real pleasure to own (I've had it from new).
We had a problem about a year ago when the wife didn't get the fuel cut-off when filling up and over filled the car resulting in fuel pouring out of the tank vent and down the fuel tank under the car but after a long drive that cleared up and has not happened again. Interestingly we didn't get any engine CEL's or have any codes turn up at all when checked by my mechanic.
Over the past couple of weeks we have noticed a very strong smell of fuel under the car around the fuel tank. I can't see any indication that there is a fuel leak but have noticed when filling up that the smell is very strong and as the car runs the fuel down the smell reduces to almost nothing.
Today I removed the rear seats and the fuel pump access panels to see if there was any seeping around the pump gaskets but couldn't see anything and the top of the tank around the both pumps was a dry as a bone. Using a torch I did however notice that there was a darkening of the fuel tank surface in the centre which I guess is close to the vent valve, part 311990b:
Or maybe is where the fuel vent pipe runs to?
Elantra XD (2001-06) :: Light Fume / Fuel Smell In Cabin
2003 Elantra GT (hatch): Over the past month I've been smelling fuel in the cabin. It's more of a light 'fume' kind of smell rather than a heavy fuel smell. Here are some observations:
- It smells most of the time but not always, and it varies in intensity.
- It doesn't seem to be affected by whether the car is moving or not.
- I can't isolate where it's coming from.
- You can also sometimes smell it outside the car.
- I don't see any puddles under the car.
- Not sure if this is related, but about once a month the car has real trouble starting. No apparent rhyme or reason to that, and no codes.
I've had it looked at and the shop said they didn't see anything. They did a smoke test. I don't have 100% confidence in their competency (but they're fantastically nice!). They thought it might have been residue from a previous repair they did - because their technicians aren't clean and might have gotten it in the car?!
I read a similar problem where people suggested a seal on the fuel rail dampener.