Ford Aerostar :: Fault Codes From ABS System / Engine Cranks But Does Not Start
First, how can I get the fault codes from ABS system? I cannot find the connector from where to activate it. Looking for a picture where is it located, and how does it look letterike?
Second problem is with starting, occurs sometimes. I just crank the engine, but it doesn't start, when I play with gas pedal, then it will start with 2-3 cylinders, runs really rough for half a minute like this (I hold the gas pedal down, otherwise would die), then gradually gets better until normalizes. Some other time, starts and runs fine. It could happen both with cold or warm engine.
Celica :: 1991 GT Cranks But No Start - Blinking Engine Light / Code 12
My cousins car died. cranks but NO start. It was not very well taken care of, but it is her daily driver. Threw a code 12, which is SOMETHING with the ignition.
Have replaced the...
distributer/cap/rotor
spark plugs
wires
ignition coil
valve cover gasket [unrelated HUGE oil leak]
100a ALT fuse
Timing is correct as far as i can tell, 12 volts at both wires for the ignition coil
Battery is good, alt is good...
Passat (B5) :: 1991 - Engine Cranks Well, But No Fire
1999 Passat turbo with a little over 100K miles. Car ran fine last night. This morning, the engine/starter cranks well, but no fire. And it has gas in the tank.
View 1 RepliesFord Aerostar :: 1991 - Stalls When Put In Gear
My engine stalls when cold or warm, when put in gear or idling in gear at a stop. If I left foot break and give a little gas I can usually keep it going. I ran 2 bottles of fuel injector cleaner through, but no dice. Could the fuel filter need to be replaced? If so, where is it located? 1991 Aerostar 3.0 Auto RWD
View 14 RepliesFord Aerostar :: 1991 - Steering Box Leak?
It would appear as though my steering leak on my 1991 Aerostar is coming from the seal, where the steering shaft enters the steering box. I'm trying the Lucas treatment but it doesn't appear to be working. Can this seal be replaced WITHOUT replacing the entire steering box?
View 6 RepliesFord Aerostar :: 1991 - How To Check ATF In Transfer Case
Where/how to check the ATF in the transfer case? I found the lower drain bolt,but I don't see anything up higher that looks like a fill hole.
'91 Aerostar 4.0L AWD
Ford Aerostar :: 1991 - Running Rough / Very Low Vacuum
1991 aerostar 4.0 ... My van was running well til last week.it allegedly has 77000 miles on it. It started running really rough within a 50 mile period. I've quit driving it til I am sure. I am not harming it. I put a vacuum gauge on it. It wildly fluctuates between 3 and 7 pounds at idle. I've tried plugging the four vacuum lines one at a time to eliminate the accessories as the problem.the check engine light is off and my scan tool shows no codes.i unhooked the exhaust at the manifolds to make sure the cats aren't clogged.it doesn't have egr. There's no water in the oil or bubbles in the radiator.i have a compression tester but id like to avoid trying to get to the plugs unless necessary.
View 5 RepliesFord Aerostar :: 1991 - How To Remove Roof Rack
How to remove roof rack on 91 Aerostar? Google and search box here yielded no result so a new thread is likely in order. I have leaky roof. Not windows.
View 8 RepliesFord Aerostar :: 1991 - Freeze Plug Leak While Driving
I developed a freeze plug leak while driving into town in my 1991 Aerostar with the 3.0 liter engine. Got to Schuck's (my destination) and bought some antifreeze, noted where the leak was and filled up the coolant system.
Drove a few miles to the mechanic's house. Coolant blowing out everywhere, obviously boiling off. Let it cool down while going over an estimate for repair. Topped it off one more time and went home. Have not moved it since.
There is sludge, almost like thick foam, that I suspect is what's left of coolant that has had the water mostly removed. It is the same color as the coolant - bright orange-ish green. Will a few flushes with fresh water clear this out of the system?
Ford Aerostar :: 1991 - Interior Door Panel And Windshield Compatibility
Will interior door panels from a '91 Aerostar fit a '96? No power windows or locks. The panels in our '96 are busted and I found a good set in the salvage yard in a '91. Lady at salvage yard says they're different, but I'm not so sure. Also, will the windshields swap?
View 3 RepliesFord Aerostar :: 1991 - Shift Cable Popped Off Gear Select Lever
I have a 1991 Aerostar 2wd 3.0. I recently had freeze plugs replaced and the mechanic had to drop the tranny to get to some. Now the shift cable has come off the gear selector lever. I have googled everywhere and can't locate the procedure for reattaching it. My mechanic was doing the work on the side and charged me only labor for his assistant. He is at work right now..
View 5 RepliesFord Aerostar :: 1995 - Cranks But Won't Run - No Fuel Pump Power
My issue. 95 short Aerostar, Vulcan engine, A4LD trans. Just got it last week. Bought a new trans and when I went to pull the van into the shop, it wouldn't start. Cranks but won't run. First thing I checked is fuel pressure, got zero. Pulled the kick panel and found the inertia switch, but the harness for the switch is getting 1.8 volts with the key in "ON" and the same with it in "START". IIRC it should be zero in RUN after a second or two (if the engine isn't actually running, that is), and 14 in START.
Checked all fuses in the panel by the steering column, they're good, and switched around the 3 relays by the battery. No good and I don't hear the FP relay when I turn the key. For now I'll run wires directly from the battery to the pump, just til I get the trans done, but it needs to be fixed anyway because I plan to make this van a DD. Here are my questions:
-Is there a second fuse panel I didn't find?
-Could this be a computer issue? If it is, would the computer fuse be blown?
Ford Aerostar :: Engine Cranking While At Start Up And After Turning Off?
I've got a 1993 Ford Aerostar XLT. Was running great until yesterday, when I turned the ignition and got nothing but a click every time the key was turned. Checked the battery (had power), bridged the relay (just got clicks but didn't turn over)....so I concluded the starter was bad.
I installed a new starter motor/starter Selinoid today. The van started right up, but next start the engine kept cranking (even while van was running and after shutting off)...I had to disconnect the battery cable for it to stop. Next start the problem didn't persist...but the time after that it happened again.
Any thoughts as to what is going on, or where to start in tackling this problem?
Ford Aerostar :: Power To The Van Just Quits - Engine Not Turning Over To Start Up
All of a sudden all the power to the van just quits when I try to start it. I put a load test on the battery and it seems fine. I've still got power at the battery terminals when everything is dead - no dome light or anything else.
We went out for lunch and had to get a jump to get back home. The battery was turning the engine just fine before this sudden event. What would kill all the power to everything every time I try to start it? After some time goes by, the dome lights and chime come back but I can no longer turn the engine over to start it up.
Ford Ranger / B-Series :: 1994 - Engine Cranks But Won't Start
My kid is using my 94 Ranger with 215,000 miles. It quit while he was on his way to work. Engine cranks but won't start.
Fuel pressure at rail was 12 psi (Key on eng. off). I replaced fuel pump. Pressure at rail up to 20 psi. Still cranks, no start.
I replaced fuel filter. Pressure at rail up to 30 psi. Still cranks, no start.
Replaced distributor cap/rotor and plugs. I have spark at plugs.
Chiltons from 1994 doesn't list a rail fuel pressure. I see new fuel pressure regulators are set at 41 psi. I pulled mine and hooked air to it. It (FPR) cracks at 37 psi. I have lots of flow returning to tank, so I assume the fuel system is working correctly. I've never replaced the timing chain/sprockets. Distributor rotor spins during engine cranking. When I rotate the crank pulley to 0 Top Dead Center the rotor is pointing to #1 on the distributor, so I don't think the timing chain has skipped a tooth on the sprocket??????
Ford F-150 - 1997-2003 :: Engine Cranks Over Fine But Won't Start?
The Engine cranks over fine, but won't start. When it does start everything is okay and it runs good with no codes. I noticed that by taking the key out of the ignition, I was checking under the hood, and put it back in the truck fired right up. Also it has never done this to the second driver who has a different key. The truck runs fine at all speeds and loads, even when hauling twenty bags of wet mulch. It's a 2001, 4.6 L, RWD. Could the PATS Chip be failing?
View 9 RepliesFord F-150 - 1997-2003 :: 1998 4.6L - Engine Cranks But Will Not Start
I have a 98 F150, 4.6L with approx. 245,000 miles on it. recently it started, then studdered a little bit and died. I managed to get it re-started, it then shuddered a little more although I was able to drive it back up the drive way and park it. Now, it will crank however it does not even attempt to fire. The sound that it makes when trying to start seems odd to me. Like the engine is just turning against a constant resistance instead of the normal starting sound. I tried shooting a little starter fluid into the throttle body and nothing changed. I pressed on the shrader valve and got a spew of fuel to come out so it seems that it might not be a fuel problem though it sure sounds like one. Just curious, what are the symptoms of a truck with no compression?
View 4 RepliesFord Aerostar :: 2002 - Spit And Sputter And Check Engine Light Start Blinking
My 2002 Windstar SEL has been giving me a fit and I`m not getting any codes as to why. Here`s the 2 main issues. Clicking when i go to start up in a.m. if it`s below 50 degrees. ( Battery has been checked and all is o.k. or so I was informed). As long as it`s warm it starts fine every time. Also,it seems like the least bit of wet on the underside will cause it to spit and sputter and the check engine light will start blinking until it sits and dries for a while. (A very shallow puddle less than 6 inches deep at low speed or even the automatic car wash that sprays the undercarriage).
View 2 RepliesFord - Ranger :: 1995 - Starter Cranks / Engine Turns Over But Will Not Start
I have a 1995 Ford Ranger, manual shift. It always starts when cold, but sometimes -- very sporadic -- it will not start after I've gone somewhere. This has happened maybe 8 times over the past 18 months or so. Always, after sitting a while, it starts right up as though nothing happened. Several months ago I left it with a mechanic for an entire week, but he could never get it to act up. Of course.
In browsing through these discussions, I've seen the "starter/clutch interlock switch" mentioned. Here is my question, though. Would the starter still crank if that was the problem? or does that switch stop the starter from engaging?
When mine acts up, the starter cranks, the engine turns over ... it just acts like it's not getting fuel. Is that a starter/clutch interlock switch issue? Or something else?