Ford 6.7L Power Stroke Diesel :: TPMS Warning Light When Not Towing
For the last couple months when not towing I take the front tires to 65 psi and the rears to 50 psi. It gives me the warning light which I click OK to every time I start it. This weekend I put everything back to 80 psi getting ready to tow and I can't get the warning light to go out anymore. I double checked my pressure to make sure everything was OK and it was. I will be taking it in unless someone knows a reset or something else to check out before I do.
View 8 RepliesFord 6.7L Power Stroke Diesel :: TPMS Warning Go Off On The Road
Had my TPMS warning go off yesterday on the road 400 miles from home. Checked all the tires, all within spec and continued on. But started to wonder if the spare tire also has a TPMS unit and it could be the spare fell below the threshold. I have not checked it yet, but figured I would ask if the spare also has TPMS.
View 14 RepliesFord 6.7L Power Stroke Diesel :: TPMS - Low Tire Pressure Light Won't Go Away?
I had the low tire pressure message and light come on back when i was visiting california, about 3 weeks ago..i checked the tire pressure, and a couple tires were maybe 5 psi low at the most.. i aired them back up to the right pressure (as stated on the door pillar sticker) and the damned light/message is still coming on.. how do I reset the TPMS? it says in the manual to just drive the truck 20mph+ for about 2 mins after getting the tire pressure correct, and the light/message should turn off. i have done that...
View 14 RepliesFord 6.7L Power Stroke Diesel :: Tire Pressure Is Correct - TPMS Light Will Not Go Off
2013 F350 SRW . Pressure is correct . Anything special you need to do to make the light go away ?
View 14 RepliesFord 6.0L Power Stroke Diesel :: Alternator Warning Light And Lose Power Steering Soon After Brakes Got Stiff
I just wanted to share with you all a cautionary tale about belt tensioners and idler pulleys. I am now a firm believer in installing the aforementioned items when you replace your drive belt. 15000 miles ago I replaced the drive belt and didn't heed the warning of some here on the forum.
For the last month or two I have noticed what sounded like road noise which I dismissed because I had just had new tires installed that had a more aggressive tread pattern than my previous tires, I also noted that the ECT had been a bit higher than normal, like running in the high 190's to low 200's on average.
Well while driving today I get the alternator warning light and lose power steering and soon after the brakes got stiff, this was followed by ever increasing ECT which got to 242* before I could get it off the road and shut down. It is too early to tell if the noises and the ECT temp rise were the result of this tensioner going out...
For what its worth the only tools required were a 10MM end wrench and a bit of skin to get the job done.
Ford 6.7L Power Stroke Diesel :: Water In Fuel - Warning Light Came On
Not another dumb "water in fuel" post... I had the warning light come on the other day, so I got under to drain the filter. Not much water came out before the diesel, but I let some diesel drain anyway to be sure. What was strange though, was the electrical connection was off. I must have hit something somehow and pulled it out? What I'm wondering, because of the little water that came out of the filter, would the light have come on from the plug getting pulled out?
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2016 F350 - Any Way To Shut Off TPMS?
Is there a way to shut off the TPMS? Can you adjust the working pressures? My 2016 F350 which I have had now for 3 weeks, has 65psi in the front and the rear is 80psi. which empty rides like a rock. I want to lower it down to 60psi (rear). This made a heck of a difference on my 2008 Dually. Think that will cause a light?
View 10 RepliesFord 6.7L Power Stroke Diesel :: Replacing Tires Replace TPMS Sensors Too?
Got 62K on my OEM Michelin LTX-AT2 tires. Very happy with the wear. Going to get them replaced in the next month with the same thing.
Question is, what is the expected life on the TPMS sensor/batteries in the wheels? Should I be replacing those at the same time? I put about 20K miles on per year, so tires last around 3 years. If TPMS is some multiple of 3, then I am ok, otherwise I will replace them when it goes in for new tires.
Any real world experience on battery life?
Ford 6.7L Power Stroke Diesel :: 2012 F250 - TPMS Fault Code
I just bought a set of 2013 20" rims for my 2012 F-250. I can't seem to get the tire fault light to go off. I've gone through the "learn" process but it won't read them. Are the TPMS not the same between years?
View 2 RepliesFord 6.7L Power Stroke Diesel :: DEF Warning Will Not Go Out
I have searched this problem and seen where some have vapor locked or whatever. Tried banging on the tank squeezing the hose etc. Last time warning came on I pulled in and tried to fill it up and it only took between 2 and 2.5 gallons. However the warning went away. This time same thing I know it has not been long enough for another fill maybe 2k miles. So I pulled in again and got just under two gallons in it.
Warning did not go out came home got on here and learned about above mentioned problem and solutions so went to Walmart and got a bottle. Tried to force feed it while tapping on tank and squeezing hose but probably not even a half gallon and still have the warning. I drive a lot so the 455 miles I have left wont last me long. I picked it up 10/23 with30 miles on it and I am right at 30k now. So am I stuck going to the stealership?
Ford 6.7L Power Stroke Diesel :: Reduced Engine Power Warning Message Pop Up
I have seen this pop up on the truck I think 3 times now over the first 4000 miles on the truck.
Usually it's when I'm on the highway around 70mph or so.
It comes on for a few seconds, then goes away. I do have an exhaust / tune on the car.
Ford 6.7L Power Stroke Diesel :: Reduced Engine Power Warning
Getting reduced engine power warning with no other lights on the dash and what is probably causing it. The truck is a 14 f450 cab and chassis model. I had just had it to the dealer for this problem and the check engine light was on and the said there were two sensors going bad on the exhaust so they changed them out and sent me on my way. Well after driving the truck around all day and not one issue it had just decided to set the rep warning again but did not set off any lights...
View 7 RepliesFord 6.7L Power Stroke Diesel :: Reduced Engine Power - Warning
Reduced Engine Power warning and fuel leak? While towing our 37 Fiver uphill a couple of days ago, the warning popped up along with the CEL. Indeed, the truck did lose a tremendous amount of power. When I found a safe place to stop, the diesel smell was terrible. Further inspection revealed that fuel was dripping down the side of the engine from somewhere above the oil filter. I limped along another 15 miles to the campground and unloaded the 5<SUP>th</SUP> wheel and brought the truck in to the dealer this morning. They aren't giving many details of their findings thus far. They say that they've talked to Ford engineers and that they'll have to put a dye into the fuel to detect the origin of the leak. They suspect the high pressure fuel pump, but by the time they remove enough "stuff" to get to the pump, they can't run the engine to witness the leak. This is my first Ford in 30 years behind the wheel and my first diesel. After 8k miles on the truck.....
View 14 RepliesFord 6.7L Power Stroke Diesel :: CEL / Low Fuel Pressure Along With Reduced Engine Power Warning
I just had my first fuel filter change (about 9,000 miles). After the shop changed both fuel filters with factory Ford ones, a check engine light came on and a "low fuel pressure" warning, along with a "reduced engine power" warning. It also stalls a lot and takes a long time to restart.
Obviously, they didn't do it right. I suppose there is air in the lines or something didn't go back together correctly.
My '06 seemed to purge itself, but this truck obviously won't. It is not even driveable to get it back to the station, to see if they can correct the problem.
The thing is, I watched them do it, so if someone can ask me the right questions as far as what I saw, maybe I can lick the issue in the driveway myself.
Ford 6.7L Power Stroke Diesel :: Changed Fuel Filters - Reduced Power And Low Pressure Warning
Changed the fuel filters. No issues in replacing.
Primed them by the book - key on 30 seconds 6 times
Now I have low pressure warning and reduced power.
All parts were FOMOCO...
Ford 6.7L Power Stroke Diesel :: DEF Warning Not Resetting
I purchased a 2011 F350 with the 6.7 with 65000 miles on it about a couple of months ago. I have put about 3000 miles on it so far about 600 of those pulling a 30' 5th wheel. Today my 800 mile DEF warning came on so I picked up a 2.5 gallon jug and it took all of it. The last little bit went really slow so I figured it was full. I had some running around to do and the warning did not reset after about 15 miles and 3 start and stops on the engine. I read that they really need to be topped off completely do I grabbed another 2.5 gallon jug and was able to get about another gallon in. I then drove it for about 10 more miles stooping and starting 2 more times. The warning has still not gone away. Do I just need to wait a little longer or is this an indication of something I need to be worried about?
View 10 RepliesFord 6.7L Power Stroke Diesel :: DEF Warning Won't Shut Off?
I just got 500 miles to empty message. On my next trip out I grabbed a 2.5 gallon at my local auto parts store. When I had 99.9 percent of the jug in, it actually started to spit back out. I got the rest in and figured I was done. It did seem strange that it only took 2.5 as I figured it was just about empty to get this message and 2.5 would only take me half way. Anyways, a few trips later and the message is still there. Do I have a bad level sensor or was it spitting out prematurely? Shouldn't 2.5 gallons have killed the warning even if it didn't fill it?
View 14 RepliesFord 6.7L Power Stroke Diesel :: Coolant Additive Low Warning
Got a warning Coolant additive low and checked the coolant reservoir is above the cold fill line on the big reservoir and on the small reservoir(near the Radiator neck) it also is above the fill line. What could the message be telling me? The second message is "Cleaning exhaust filter" and it come and goes. Is this a warning that I need to do something about?
View 7 RepliesFord 6.7L Power Stroke Diesel :: Low Pressure Fuel Warning Came On
Low-pressure fuel warning came on two separate times Sunday ... I know what caused it the fuel gel 18 below not enough anti gel in the tank no big deal warm the truck up everything's fine now no more warning lights coming on does the dealer need to reset anything I guess I'm asking did it throw a code that needs to be cleared? Its running fine now I guess I'll just have to put a little extra in when it gets that cold wasn't expecting - 18 checked drain no water just gel up could here the pump under the truck fighting to pump for a few minutes.
View 14 Replies