Ford 6.7L Power Stroke Diesel :: How To Get Rid Of Whine After Changing Fuel Filters
2013 6.7 F350 13,500 miles... Changed the fuel filters and got them bled out and truck runs OK but have a whining noise from the engine compartment fuel filter area.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 - Change Fuel Filters At 10k Miles?
Ive had my 2011 for 20 months. I have 7,300 miles. I know the manual states changing around 22k but do you think time is a factor as well? I wont hit 22k for two years. Truck will be 3.5 yrs old. Should I just change them at 10k and see how they look? Don't want to waste the money either if its unnecessary. I use it 50/50 towing/unloaded.
View 8 RepliesFord 6.7L Power Stroke Diesel :: Mileage Goes Down After New Fuel Filters
A month ago I changed engine oil, oil filter and both fuel filters. All replacement filters are Motorcraft and my mileage is off a solid 2 mpg after the fuel filter replacement.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Changed Fuel Filters - Reduced Power And Low Pressure Warning
Changed the fuel filters. No issues in replacing.
Primed them by the book - key on 30 seconds 6 times
Now I have low pressure warning and reduced power.
All parts were FOMOCO...
Ford 6.7L Power Stroke Diesel :: 2015 - Changed Fuel Filters Now Delay In Turning?
I changed both fuel filters on my 2015 F350 6.7 I turn the key online for 30 seconds then turned it off for total of 6 times when to start the truck this morning after driving it yesterday and it took a little bit longer to turn over before it finally did, did I miss something up that I do something wrong. So I let my truck warm up this morning after going to start it at took a little bit longer for it to turn over I turned it off wait a few seconds then turned it back on and she started up how she used to perfectly fine does it just need to go through a drive cycle. This is the second fuel filter replacement nothing was wrong with the other ones I'm at 40000 miles now ... also it seems like the fuel filter on the frame rail is louder if you put the filter in upside down on that will it fit stupid question I'm sure I did it right but thought I'd ask before I tear it apart....
View 14 RepliesFord 6.7L Power Stroke Diesel :: Fuel Filters Changed Now Loud Groan / Sing When Key Turned On
2011 F250 6.7 Had the fuel filters changed by the dealer today. No noticeable sounds when I left the dealership, & no fuel stops on the way home (120 miles one way). When I got home, before shutting off the truck, I heard a loud groaning/singing from inside the truck. With the truck still running, I get out, & the groaning/singing is very pronounced....never heard this before & appears to be emanating from the fuel filter underneath the truck.
I turned the truck off, then turned the key back to the position that the fuel pump turns on, and wow, the pump is very loud. Definitely something going on because when I turn the key for the pump to turn on but not start the truck, I can feel the vibrations of the pump working from inside the truck and when listening from underneath the truck, it is very loud. Before today, the truck never made this noise and never heard the pump before.
Ford 6.0L Power Stroke Diesel :: Water In Fuel Light On After Changing Fuel Filter?
Changed fuel filters today. Now my water in fuel light is coming on. But the truck is not running any different no sputtering or anything. ????? Could this be human error
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2013 - Changing Fuel Filter?
I was going to change the fuel filter on my truck yesterday, but couldn't figure out how the guard comes off. It has a bolt but it also has a rivet in it and looks like its all one piece so Id have to drill the rivet to remove. I tried to just spin the housing off.
View 8 RepliesFord 6.7L Power Stroke Diesel :: 2014 - Changing Fuel Filter?
Noticed change in power after changing the fuel filters on 6.7 .... Seems like it has a fuel restriction at times maybe even air somewhere in the line. Thought I felt the truck hesitate after hitting the gas and Cavitating when I hit the gas petal. Both new filters are motorcraft parts. I did follow the procedure after installing filters by turning the key on 6 times waiting 30 seconds in between. Could it be a problem with the fuel pump. I should say I didn't have this until I changed the primary filter.
View 9 RepliesFord Super Duty (1999-2016) :: Changing Fuel Filters On 2014 6.7L
I need to change the fuel filters on my 2014 F250 with a 6.7L. Are there any special tools required and any tips on how to get this done?
View 7 RepliesFord 6.7L Power Stroke Diesel :: Aluminum Particles In DFCM While Changing Fuel Filter?
I changed the fuel filters today and saw a couple of small pieces of what looked like aluminum or aluminum foil in the bottom. Nothing in the filter itself it still looked good. I will try to post pictures later but I'm not sure it will show up. I don't recall seeing anything the first filter change and this is the second. Is this normal?
View 2 RepliesFord 6.0L Power Stroke Diesel :: Cranks But Won't Start - All Filters Clogged
Couple weeks ago fuel tank started coming apart clogged all filters. Replaced tank filters and fuel pump and blew out all of lines. Started and ran fine. Stays plugged in over night but now it'll crank but wont start. No codes showing up or anything...
View 1 RepliesFord 6.7L Power Stroke Diesel :: 2011 - Leaking Fuel Into The Valley Slowly At 208K Miles?
I have a 2011 in the shop for a fuel leak. Truck has 208,000 miles on it. Leaking fuel into the valley. I took the upper and lower intake off and cleaned all the fuel up so I could see and with the key on there is fuel coming out from the bottom of the CP4 area where it mounts to the front cover. Looks like there is an o-ring between the front cover and the CP4 but wouldn't that o-ring be for sealing oil and not fuel? I'm confused as to how this works. Truck runs great with no check engine light. It's not a fast leak but a drip drip drip from the bottom of the engine once it fills up the valley enough to run off the back of the engine.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Changing The 6.0L Oil?
How to Choose the Right Oil
Step by step instructions for do-it-yourself repairs
Ford 6.7L Power Stroke Diesel :: First CEL Under 40k Miles?
Got my first CEL at just under 40K miles. P4023, Redundant temp sensor range, so looks like I get a new DEF tank sensor. Of course they are on national back-order still. One would have thought that Ford would finally have these in stock but no.....
View 8 RepliesFord 6.7L Power Stroke Diesel :: Changing The Oil Filter?
OK what is the trick to changing the oil filter on the 6.7 without making a mess. My last truck, which was another brand, if I would let the truck sit for a couple of hours, I could get the filter loose, put a zip lock bag around the filter, & remove the filter without any drips. With the 6.7, even if I let the truck sit overnite, it seems like the oil doesn't drain from above the filter, & as soon as it comes loose my hand gets a bath. Any tricks to changing the oil filter.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2012 - First CEL At 62k Miles?
I have a 2012 F250 6.7L with about 62,000 miles on it. I purchased this truck new in October 2013. I had my first check engine light last Friday. I scanned it and it was a P20BD (Reductant Heater "B" Control Circuit/Open) is what I found when I searched for it. I had the truck in on Tuesday to the dealer. They are telling me it is the Reductant Pressure Line and the repair will be $690. They didn't have the part so I picked up my truck and have an appointment scheduled for Monday.
Since picking the truck the check engine light hasn't returned. I find this odd and it makes me wonder if they are correct or not in their diagnostics.
The other question I have is isn't the DEF system part of the emissions system? If so why isn't it covered under the emissions system warranty until 80,000 miles or 5 years?
Ford 6.0L Power Stroke Diesel :: Third Set Of Tire At 20,000 Miles?
Well so far I have had this truck for 5 years and I'm going for the third set of tires. So far I have run Nitto terra grapplers, and currently BFG at ko's. Both sets wore out around the 20,000-mile mark, they both wore very evenly, rotated every 6,000 miles, properly inflated, check the lineup at 2 different reputable shops.is it something about the 275-65-20s that make them wear faster? I really don't need an at tire as I don't go off road that much so I'm thinking of a good all season radial.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Fan Clutch Went Out At 47k Miles?
Fan Clutch went out today 47,000 miles.
View 5 Replies