Ford 6.0L Power Stroke Diesel :: Rear Brake Smoking On Driver Side?
Any recommendations on brake calipers and hose?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2007 F250 - Rear Brake Pads Don't Fit
I bought new pads for my truck and the fronts went on with no problem at all, but when I got to the rear the tabs/ears on the pads are about 1/8 inch wider than the notch they are supposed to fit in. I bought part number BR-1067, which is supposed to fit but obviously doesn't. What part number should I have bought? My truck is a 2007 F250 Super Crew Lariat FX4.
View 9 RepliesFord 6.0L Power Stroke Diesel :: Rear Brake Calipers Hung While Traveling In Mountains
Both of my rear brake calipers hung while traveling in mountains. Both so hot that I had no brakes. Had not been riding the brakes. Had to bump them when someone pulled out in front of me. Never noticed them hanging but smelled them and then hit the brakes and no brakes. They were so hot that they blew the valve stems out of both rear tires. Once they cooled, I had brakes. What would cause both to hang up at the same time?
View 1 RepliesFord 6.7L Power Stroke Diesel :: 2016 F350 - Brake Dust On Front Wheels
I have a 2016 F350 4x4 that has brake dust on the front wheels after only 3000 miles. I have tried to find ceramic pads to replace the semi-metalic pads that are causing the issue. There is no listing for replacement pads that I can find. My question is will 2015 pads fit the 2016? What is the actual part numbers to see if they are the same. This is just one of the problems with having an early build vehicle.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Leak Coming From Front Of Rear Diff
I have a pretty good leak coming from the front of the rear diff. is this a common problem on the 10.5 ? How hard are these to do without a lift? I still have warranty left but will have to swap out exhaust so its almost a toss up whether I do the seal myself. Also was considering a new posi unit because seems like the original is about toast, might be a good excuse to swap a new one in. 2009 with 95,000 on it. Bought it a year ago with 70,000 on it, the rear was dry till at least 90,000. I serviced the fluid at about 90,000 and didn't have a leak so now a couple thousand miles and its gushing???????
View 7 RepliesFord 6.0L Power Stroke Diesel :: Oil Leaks At The Front / Rear Side Of Engine
I have had a slight oil leak at the front of the engine for a while, and slight oil leak on the pass rear of the engine, and recently got a decent oil leak in the rear drivers side of the engine. I want to fix all three leaks if I can identify what is wrong.
Leak 1 : Front of the engine. This has been leaking a drop or two of oil every few days for over a year. Slight leak so I didnt worry about it. The leak is dripping from between the crank pulley and the engine. Is it likely the front crank seal is leaking, or maybe something above it?
Leak 2 : Rear of engine pass side. There has been a slight oil leak on this side of the rear engine for about a year too. It leaks about a drop of oil a day. I can see that the oil is all over the starter though.
Leak 3 : This just started and is a decent leak. It is dripping off the exhaust manifold as seen in the picture below and leaks a 6 inch circle of oil on the ground in a week.
Maybe leak 2 and 3 are connected? I tried to get a good look of the engine and without pulling anything off, I couldn't see any oil leaks on the top of the engine. I couldn't see the HPOP cover though because the turbo was in the way.
NOTE: I do park my truck in the driveway every day and our driveway is slanted quite a bit with the nose of the truck much higher than the back.
Here are some pics of the oil leaks:
Under pass side of truck, oil on starter : [URL] ....
Under the Drivers exhaust manifold : [URL] .....
Bottom front of engine, between pulley and engine : [URL] .....
Ford 6.7L Power Stroke Diesel :: Left Side Rear Blinker / Brake Light Is Not Working
My left side rear blinker/ brake light is not working. The running/taillight side/filment of the bulb works, but the brake/blinker side/filament does nothing ! Just bought the truck used and it's my only issue, waiting on a owners manual, but I think each bulb is fused separate, and since half the bulb works, can I rule out the fuse and start chasing wires ??
View 5 RepliesFord 6.0L Power Stroke Diesel :: 2006 F350 - Front Brake Caliper Bracket Bolts
I read a reference to the front brake caliper bracket bolts being one time use torque to yield and must be replaced every time they are loosened. Is this true?
This is on my 06 F-350 in my Sig.
Ford 6.0L Power Stroke Diesel :: Coolant Dripping Off The Front Sensor On Brake Master Cylinder
Stopped after a hard pull and noticed I had coolant dripping off the front sensor on the Brake Master cylinder. Coolant level was down in the Degas bottle. Searched everywhere for the source of the leak, and couldn't see anything. Today the drip had stopped, but when I squeezed the rear heater return hose under the Degas bottle it appeared to have a wet spot form.
I'm thinking I have a very tiny pin hole, and plan on pressurizing the system to see if I can determine for sure this is where it is. Before I do though, where this high pressure leak might be coming from? Degas bottle and cap is less than a year old. Doesn't appear to be any signs of leaks around the clamps. That rear heater hose.
Ford 6.7L Power Stroke Diesel :: 2011 - Winch Wiring For Rear And Front Usage?
2011 f350 CCLB... I want to wire a hitch mounted winch for both front and rear usage.
I see several 2 ga wire kits with quick disconnects, but was wondering which battery to go to, and which frame rail side to use. The exhaust side kinda worries me due to heat. Although the drivers side has the fuel tank, and I have skid plates blocking the inside of frame, so it doesn't sound pleasant either!
Also, best method to connect to the battery terminals. It appears the battery clamp screw is smaller than standard and wont accept a large ring winch terminal. Is there a "post doubler" available, or should I consider removing the factory cable clamp and replace with a set screw block of some sort? Hate to have a warranty issue due to a non oem battery clamp?
For the limited use, I have consider just getting one of the wiring kits, and adding high amperage "jumper clamps" and running the wire only when used?
Ford 6.7L Power Stroke Diesel :: 2012 F350 - Loud Grinding Noise In Rear End Like A Brake Locked Up
Just over 7000 miles all of a sudden I got this loud grinding noise in the rear end like a brake locked up. Pulled into a parking lot. Don't think it's brakes. Put the truck in reverse it got even louder for a second then it quieted down after that. Naturally this happened on a Saturday.
View 6 RepliesFord 6.7L Power Stroke Diesel :: Clunking In Front Brakes After Replacing Brake Pads And Turning Rotors
Ok so we just replaced our front and rear brake pads and had the rotors turned. Our rear brakes are fine but both our front brakes now make a clunking/popping noise when we brake.
View 4 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Front And Rear Passenger Side Pulling Only In 4WD?
Got stuck, noticed when in four wheel drive only the front passenger side and rear passenger side was pulling. Is that normal? Or should both fronts be pulling?
2011 f350 dually 4x4 6.7.....
Ford 6.7L Power Stroke Diesel :: Rattle In Left Front Wheel / Little Whine Coming From The Rear
So I went to the car wash this morning and when I pulled into the stall I heard a somewhat loud rattle coming from my front drivers side wheel. It sounded like there were a couple stones in the cap that covers the lug nuts. That wasn't the case. It did it in reverse also. Before I take it to the dealer Monday morning. Its a 2011 F-350 6.7 Lariat 4x4 w. 32,000 miles. I also have have a little whine coming from the rear when I take off from a standstill.
View 4 RepliesFord 6.7L Power Stroke Diesel :: F350 - Rear Parking Brake Sticking / Wheel Started Smoking Severely?
A few weeks back my rear drivers side wheel started smoking severely...when I stopped you could smell the brake material, feel the heat coming from the wheel, and lots of smoke. I speculated it was the parking brake that got hung up. I jiggled that cable around and then went around the block - no issue. Note: I did not leave the parking brake on.
It happened again a week later, but not as bad. I took it into the dealer today. They said heat was evident as it burned off a sticker on the disk or caliper hsg area. They have not determined yet if it is parking brake or caliper?
Ford 6.0L Power Stroke Diesel :: Changing The 6.0L Oil?
How to Choose the Right Oil
Step by step instructions for do-it-yourself repairs
Ford 6.7L Power Stroke Diesel :: Changing The Oil Filter?
OK what is the trick to changing the oil filter on the 6.7 without making a mess. My last truck, which was another brand, if I would let the truck sit for a couple of hours, I could get the filter loose, put a zip lock bag around the filter, & remove the filter without any drips. With the 6.7, even if I let the truck sit overnite, it seems like the oil doesn't drain from above the filter, & as soon as it comes loose my hand gets a bath. Any tricks to changing the oil filter.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Changing The Transmission Filter
New to me 2006 F350 6.0 dually. Going to change oil and filter as well as the transmission fluid.
Should I replace the transmission filter on the Auto I have or just have Jiffy Lube do their thing?
Ford 6.7L Power Stroke Diesel :: Fan Shroud Must Come Off For Changing Belt?
Changing serpentine belt? I have to but was looking for some pointers or tips. I assume the fan shroud must come off?
View 14 Replies