Ford 6.7L Power Stroke Diesel :: 2016 F350 - Low Oil Pressure Light
My new 2016 F350 6.7, every single time I start the truck, I get the low oil pressure light. Even after letting the truck idle. I'm concerned because I have no gauge inside to see what it's running and I also have what sounds like a can of rocks noise at idle and when I'm slowly accelerating I hear a clacking noise. Is this normal or should I be headed to the stealership? Truck only has 1100 miles. I've owned it 3 weeks and this is really making me wonder. I forgot to add that I'm in Louisiana and it's not often really cold. It was 84 today and I had the same thing. Even after I drove it and turned it off. Started it back up, same light.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2016 F350 - Reduced Engine Power
2016 F350 6.7; ccsrw, 22K on truck (zero issues previously). Stock other than titan fuel tank that was installed at 100 miles.
700 miles into todays trip, pulling trailer, snowing, in 4x4, tow/haul; pulled out to pass, got into it for a bit and got "reduced engine power" error, truck slowed, would not show boost on gauge, wouldn't rev over ~1900. CEL is on.
Pulled over, stopped, checked under/over and didn't find anything. Shut off truck, started back up, CEL is still on, but truck runs OK. Ran for another 20 miles or so and was OK for how I drove it (including boost showing on gauge). Not hot rodding, crappy road conditions (snow). Got on a big hill from dead start and got into it a bit, about 3K same error came on and she went back into limp mode. Same deal, stopped, shut off, back on, was able to keep going. Was only couple miles from motel at that point, so she is on break right now.
Of course I'm 400 miles from home and nowhere near a dealer. I have a code scanner, but nothing with me to pair it with (daughter has tablet with her, ha ha).
Should I keep going or find a dealer/tow/other? If she will keep running "normally" below 3K, then I can make it home as I don't need to horse it that bad on the roads I'll be on.
Truck has had fuel filters replaced on schedule, dealer has done all service work (oil, etc). Fuel filters were done 7500 miles ago.
This trip, was on third tank of fuel. Had just put in 30 gallons at last (big) truck stop about 15 miles before this issue happened, have 50 miles on this tank. That was 30 gallons into 50 gallon tank.
Ford 6.7L Power Stroke Diesel :: How To Manually Turn On Dome Light
Can't figure out how to turn on dome light, so I broke down and did the un-thinkable, I read the manual.... from page 66
Press and hold the top of the control to the full on position to activate the "dome on" feature. This will turn on the interior courtesy lights. The lights will remain on until the bottom of the control is pressed.
[URL] ......
And no luck. Can hold the button down for a long, long time. The dimmer function works OK so the buttons are working. I would like to be able to turn on the rear light so my kids can buckle themselves.
Ford 6.0L Power Stroke Diesel :: 2005 - No Dome Light - 3rd Brake Light Quit Working?
I have a 2005 F250 with 6.0 Crew cab
Wanted to change out factory bulbs to LED's. The factories were working just fine, just wanted LED's. Broke a couple of center bulb holder's/clamp. Don't really know what they are called. Went to junk yard got a couple of used ones, those worked because when we opened the doors on wrecked trucks Dome lights came on! Got home put them in and NOTHING. No dome, no map lights with LED's. Changed back to factory bulbs and only map lights come on, NO dome lights on front or back and my 3rd brake light quit along with the 2 bed lights. Checked the wiring plug and have power to one wire. What fuses would I need to check or to check where next? Owner's manual is not very specific about which fuse.
Ford 6.0L Power Stroke Diesel :: No Power - Only Accelerate At One Constant Speed While Driving?
My f350 6.0 has seem to have lost its power, while I was driving home it would only accelerate at one constant speed, and driving up hill it would not accelerate at all, I also noticed an elevated exhaust temperature.. There are no warning lights or dash lights indicating any problem.....
View 8 RepliesFord 6.7L Power Stroke Diesel :: 2016 F350 - Any Way To Shut Off TPMS?
Is there a way to shut off the TPMS? Can you adjust the working pressures? My 2016 F350 which I have had now for 3 weeks, has 65psi in the front and the rear is 80psi. which empty rides like a rock. I want to lower it down to 60psi (rear). This made a heck of a difference on my 2008 Dually. Think that will cause a light?
View 10 RepliesFord 6.7L Power Stroke Diesel :: 2016 F350 Started Losing Speed Down To About 58 MPH
I have a 2016 350 dually with 6.7, with 2,200 miles. I was pulling my 11,000 LB travel trailer on fairly level ground, major interstate going 65mph. Noticed I started losing speed down to about 58mph, then started decending a long 5-6% grade, at this point I was running at 3/4 throttle to maintain speed. It felt like something was binding like the rear or engine was seizing up. No codes, all temps were fine. Transmission stayed in 6th gear, even at 3/4 throttle.
Checked trailer brakes, didn't seem to be dragging. Engine sounded like it was really laboring like it was tightening up. This lasted about 10 minutes, very slowly power seemed to return to normal but it was not noticeably changing. Fuel was 3/4, DEF was filled about 300 miles earlier. This truck since new feels like it has 150HP less than my 2011 F250 with the 6.7 I traded it on. Not sure what to do, if I take it back, if they find nothing then I'll get a diagnostic charge.
Ford 6.7L Power Stroke Diesel :: 2016 F350 XLT - Terrible Shake During Regen
I purchased a 2016 f350 XLT 6.7 it's basically two weeks old with roughly 1500 the horsepower and fuel economy is incredible however it's developed a terrible shake during regen. It occurs every time regen and shifting down isn't working. Hard to believe a two week old truck has to go back to the dealer and from what I'm reading it sounds like they're not solving it.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: 2007 - No Power To Radio / Windows / Dome Light?
My buddy is selling his truck in a couple days and was taking out speakers, afe intake, and satelite radio. I go to start the truck and i have no power to windows, no power to radio and no domelight when i switch it on and off. Dont know what i did but none of this works and everything else does.
I checked all fused all were good. I searched the forum for a solution and they said something about the automatic delay relay and i bought a new one and nothing still. I am not sure what else to do i checked with voltmeter if i had anypower to the window or radio and nothing. But the radios clock works and when i turn on the light it illuminates but doesnt turn on.
The truck is a 2002 7.3L Crewcab. f350
Ford 6.0L Power Stroke Diesel :: 2004 F350 - Battery Light Came On
Battery light came on today. Checked voltage with truck running and only getting 11.8 / 11.9 volts at each battery. Alternator shot or ????? 2004 F350
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2016 F350 - Brake Dust On Front Wheels
I have a 2016 F350 4x4 that has brake dust on the front wheels after only 3000 miles. I have tried to find ceramic pads to replace the semi-metalic pads that are causing the issue. There is no listing for replacement pads that I can find. My question is will 2015 pads fit the 2016? What is the actual part numbers to see if they are the same. This is just one of the problems with having an early build vehicle.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2016 F350 - Can't Find Block Heater Connection
Well, I swapped a 2011 F250 SC for an F350 CC and I really enjoy driving it. 300 miles on the clock. My old 250 had the block heater and the pigtail to plug it in was low in front of the radiator. This truck also has the block heater, but I cannot find the pigtail to plug it in. In 2016 where Ford hid it at?
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2016 F350 - Metal Shavings Clogged One Of The Injectors
I have a 2016 F350 disel with 2500 miles. It's at the dealer now they are telling me some metal shavings clogged one of the injectors. What should I be looking for?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2004 F350 - Check Gauge Light Came On And Tow Haul Light Started Flashing
Friday I pulled my steel gn 3 horse trailer about an hour each way. with the horses it weighs right at 7000 pounds. no issues. Saturday morning I drove to town, no issues. Saturday evening, I got in it to run down the road and about 2 miles from the house, the check engine light came on and the tow haul light started flashing and the temp gauge is dead. drives and shifts normal, tow haul button still functions. Truck is stock except for an EGR delete. No tuner, FICM was rebuilt. I had it on a battery minder before I left and was thinking about pulling the batteries and letting it sit for a while to see if it clears. Scan Gauge II shows no codes.
Sunday: So I let it sit all night, batteries connected and it was completely normal this morning. will see what happens when I drive it to work tomorrow
Later Sunday evening: So I just took it out for a test drive, went a couple miles down the road, shifting normal for a cold start. Temp gauge is working, just as I am almost back home. 5 miles at the most, temp is coming up to normal, gauge goes dead and check gauge light comes on and tow haul starts flashing. I think it might be the sensor.
This morning: I got about 6 or 7 miles from home, trans just got up to temp, pulling up a hill, it shifted out of overdrive, tft gauge went dead, check gauge light came on and the tow haul light started flashing. still shifts like it always has and the tow haul button still functions.
I am thinking it is just the temp sensor. Truck has 159k on it.
Ford 6.0L Power Stroke Diesel :: 2003 F350 - Intermittent Battery Light On / Off
I have a 2003 F 350 Crewcab 6.0 liter SD. I was preparing my truck for the first haul of the Summer. I noticed that my batteries were on their way out after 2 years old. I replaced them and noticed I had an intermittent battery light coming on/off on/off. It seemed like only at lower RPMs. So the day of my trip, I ended up changing out the alternator.
The trip went fine, however, I noticed that pesky battery light came on and then off a few times. I also got a hot plastic type smell from the front of my truck.....you know that hot plastic smell Anyway, I got home just fine. Via Torque Pro, my battery volts were reading 12.2ish when my battery light came on, but then would quickly return to 13.9.
Since I"ve been home, I have read about fixing the grounding points for our trucks and also adding a second ground wire and a second hot wire from battery to battery. I can not find exactly where the ground's lead to. I still have that fricking battery light coming on .....more often that not. How to chase this problem.
First I need to find out where the ground wires go to. My volts of recent have been reading 11.5-12ish when the truck is running and the friggin battery light is on. I did search and found a few links to this problem, but where to find the grounding points.
Ford 6.0L Power Stroke Diesel :: 2004 F350 - Battery Light On - Won't Start - Starter?
am in possession of my fianc's F350. The battery light kept coming on, I changed both batteries... twice. I pulled the alt and took it to 2 different stores, asking them each to test it twice, and it checks out good. Drove it to a family function in Sept and it died (no lights, no dings, just completely dead), couldn't get it to jump so I had to have it towed. Tow truck driver said it was probably the starter solenoid, but I couldn't get any confirmation. Had a charger/jumper hooked up to it and got gage movement, dings and heard a clicking sound when I tried to start it.... still no jump. Is this a starter issue, or an electrical issue?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2007 F350 - Light Blue Or Whitish Smoke?
2007 F350 CCLB, Still stock, 130k miles. SCT Tuner for towing and MPG (canned tunes).. I am new to the diesel world so just making sure.
Since we started getting colder mornings I have noticed a small amount of white, or blueish white smoke on start up for about 5 secs or so. Last week in Montana I did notice the light smoke for about 5 secs then looked like vapor for about 1 min (was about 30 degrees out)
Only during the first start of the day on cooler mornings (45 and under) have i noticed it, nothing while driving, no knocks or hard start, no codes. I am about due for an oil change (Delo in there right now but switching to syn), and do have the canned tow tune from SCT on there. Anything I should have checked or should check, I am decent with wrench.
Also I have noticed the blue sleeve that goes to the front of turbo coming from the front of the truck (maybe the cooler?), kinda looks like rubber gets a slightly dirty coating to it, not sure if normal or related.
Ford 6.7L Power Stroke Diesel :: 2016 F350 - Flutter Comes On When Truck Goes Under Load For A Short Period Of Time
I have a 2016 F350 Powerstroke fully deleted for about 3k miles. Truck was running perfectly then out of no where started running like crap and had very minimal power 500-2000rpm. Once 2000rpm hit, turbo spooled up and made power. Very odd. I cleaned out back pressure sensor, map sensor and hoses. No fix. Did a hard reset and the truck ran fine again and had low end power.
Ever since then I started hearing very odd fluttering sounds coming from what I think is the turbo. Also noticed my OEM boost gauge doesn't work. No reading from it.
The flutter only comes on when the truck goes under load for a short period of time and then I let off the throttle. It seems to running fine other then that and maybe a little bit more sluggish then normal. Any things I can check before I put it back to stock and bring it to the dealer?
MODS:
NO Limit EGR Delete
Flo-Pro 5" Straight
S&B Intake
SCT Livewire w/ custom tunes
Also, I had a lot of problems with my live wire software. I have to send it back to SCT to get warranty problems fixed which I'll be sending out Monday. They think my tuner is stuck in demo mode for some off reason.
Ford 6.7L Power Stroke Diesel :: 2016 F350 - White Crystals Around The Reductant Injector - DEF Fluid Leak
Recently while changing the oil, I noticed a great deal of white crystals around the Reductant Injector. This is the point where DEF is injected into the exhaust. There is a heat shield around the connection and that shield was moved up by the growing crystals.
The hose that connects to the injector is simply one of those press lock types, i.e., you press on either side of it to remove it, and it simply locks in place by pressing it on the tube. This is the point where it seems to be leaking.
I have been tracking my DEF usage pretty close and I seem to get around 4900 miles from five gallons of DEF. No towing whatsoever, daily commuter 30 miles a day.
It's a 2016 F350 6.7 PS with 12,000 miles.