Ford 6.7L Power Stroke Diesel :: 2012 - Coolant Leak From Lower Radiator Hose
Just had to replace radiator at 38k on my 2012 SD. Now I have another leak at 41k. Looks like it's wherever the lower radiator hose leads. Kind of a weird junction. I don't think it's coming from above there, but not sure. It's the primary dgas bottle that was low. The radiator was covered under my ESP. We'll have to see what's up with this one. Been eying a denim blue SD at dealer, thinking this is going to talk me out of it though. Not especially happy right now.
View 3 RepliesFord 6.7L Power Stroke Diesel :: 2012 F350 - Transmission Pan Bolt Torque?
Searched with no results. What is the correct bolt torque for transmission pan bolts on a 2012 F350 6.7L?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 F350 - Transmission Lines Not Working?
I have a 02 f350 4x4 6 SPD one of my transmission lines has went bad is there anywhere that sales them.
View 1 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Removing Transmission Cooler Lines?
06 6.0 How do I remove the trans cooler lines from under the truck? I've got the lines hanging free they're unscrewed from the transmission and trans filter but I can't seem to snake them out to replace them. How is this accomplished?
View 7 RepliesFord 6.0L Power Stroke Diesel :: Transmission Cooler Lines Rusted And Started To Leak
Can I change these out to hydraulic hoses with clamps that are rated for the fluid. Mine are rusted and starting to leak.
View 6 RepliesFord 6.0L Power Stroke Diesel :: Coolant Leak / Hole In Radiator
I am in the middle of a several thousand mile road trip, and I am with family in Utah when this evening I noticed a puddle under my 6.0 Excursion.
Coolant leak? - YouTube
The fluid does not smell like typical coolant, but from the location of the drip, I cant think of it being anything else.
Ford 6.7L Power Stroke Diesel :: Coolant Leak On Driver Side - Radiator Leaking?
On Friday am I noticed a 6" sized puddle on the garage floor. Coolant leak on the drivers side coming off the frame. Dropped it off at the dealer on Sunday and today the tech tells me it was in fact a radiator leak and the new one will be here wed. They hope to have it buttoned late Wednesday. I am assuming all will be covered under warranty.
I have 23k miles logged and had just got home from a 1300 mile run pulling about 18k worth of hay and trailer. Truck performed flawlessly. Averaged 11mpg for the trip. I am hoping this is the first and last radiator replacement I have to go thru.
Ford 6.0L Power Stroke Diesel :: Radiator Hose Split While Traveling - 250 Degree EOT After Coolant Loss
Recently I had a radiator hose split while traveling. The EOT got up to 250 degrees before I could pull over and stop the truck. I flushed the cooling system with water, replaced the thermostat, and added Ford Gold coolant as per the recommendations in the Tech folder. My oil temps are higher now than prior to this incident. Unloaded on a flat road my deltas are about 10 to 12 degrees @ 60 mph.
My water temp will stay around 190 to 195 degrees while my EOT have reached 212-215. I pulled a small utility trailer and saw a delta of 17 degrees this was at about 75 mph. Typically unloaded I would only see a delta of about 8 degrees and this was at 80mph. My question is do you think a EOT of 250 would burn the oil, I had Shell Rotella T5 5W40 in the engine. Would it be possible that the oil cooler is partially plugged from this temp?
Ford 6.0L Power Stroke Diesel :: Losing Coolant / Radiator Making A Sloshing / Gurgling Noise
I have a 2003 6.0l... When I first bought truck, seemed to run fine. Since then truck has broke down on me once. I took it on a six hour drive, and couldn't turn vehicle off, because if so, truck wouldn't start back up until cool. After getting to my destination, fans seemed very loud every time I pressed pedal, and seemed very sluggish. Drove it a couple days and boost was low and fans continued to sound like they werre engaging even when I first started truck for the day. Had truck towed to shop, because it cut off on me when driving.
At shop : Truck had air filter, water in fuel sensor, o-ring for draining plug, new ICP sensor and harness, and HFCM cleaned up as it was filled with gunk.
After shop : Fans quit being so loud, but have not had near the boost I had before issues started. Truck struggles to go from stop, and around 15 psi boost gauge starts shaking erratically. Also, I have been losing coolant in a short period of time, and can't see any leak coming from anywhere, and also my radiator has been making a sloshing/gurgling noise and it will stop, then come back all within bout ten seconds. And I guess while I'm writing, I should mention the bucking after it downshifts in about third or fourth gear giving it gas makes the truck buck until the RPMs are above 2000 or it upshifts or downshifts, and at an idle seems to miss until warm.
Ford 6.7L Power Stroke Diesel :: Radiator Leak - Puddle Of Coolant Under The Right Front Driver Side
My truck just passed the 3 year/36k by 2 days! I got it on 8/4/10 but it only has 27,000 miles of course I just found a puddle of coolant under the right front drivers side. After a little reading, I guess this is common. Should I push for Ford to fix it or get an extended warranty and turn it in on that or... Aftermarket yet that isn't half plastic like this stock POS?
View 12 RepliesFord 6.7L Power Stroke Diesel :: 2012 - Radiator Seam Leaking
Read that this is a common issue, leaking out crimped seam on lower LH (2012 F250 King Ranch). I have called Ford customer service twice, they said "we do not have any recall or programs to cover the out of warranty repair". I keep adding coolant and thinking eventually Ford will address this problem. They did cover my bad EGT sensor....
View 9 RepliesFord 6.0L Power Stroke Diesel :: 2004 F350 - Oil In Coolant
I have an 04 f-350 that I did an EGR delete, new Ford oil cooler, new radiator (not ford), new thermostat (not ford), coolant filter, glow plugs and harness, MBRP theoretical 4in downpipe (was 3.5 to converter) flushed cooling system with lots of tap water before the delete, replaced coolant with Cat 1 ELC and distilled water, fresh T6 5W-40 and filter, several weeks ago. Was troubleshooting a wireing problem and found what looks like oil sludge in the degass bottle while under the hood.
Possible that while doing EGR delete I clipped a gasket? Truck runs great, no smoke out the tail pipe. There is what looks like about a cup floating on top the coolant. Oil level is down about a 1/2 quart and clean, no water in it. Where do I start looking?
Ford 6.7L Power Stroke Diesel :: 2015 Small Drip Of Coolant Coming From Corner Of Radiator Near Drain Valve
Have a 2015 King Ranch with 72k miles. I noticed today a small drip of coolant coming from the corner of the radiator near the drain valve.
The truck is deleted however before it was deleted I did purchase an extended warranty through Flood Ford. What are the chances they will deny a warranty claim on this because of the dpf and egr delete?
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Coolant Additive Check Message
Got the warning on the message center.. 2011 F350 38,000 miles. I am not original owner, has lifetime POWERTRAIN so thinking of letting dealer handle this,,,but..?
With the importance of these cooling systems.. and coolant being in there for approx. 60 months.. I am thinking why pay for test kit or pay dealer to test it and add additive...
I guess I could just buy the oem coolant and distilled water and drain & fill it myself... but can I use garden hose to flush? Or just better to let FORD handle it?
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Lost One Gallon Antifreeze Coolant
Had my oil changed on my 2011 F350, and the tech said that I lost one gallon of antifreeze coolant. Where could the coolant have gone? We could not find a radiator or hose leak. I am afraid that the coolant somehow got into the engine oil, and may have damaged the engine. I have 46000 miles on the truck.
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2005 F350 Leaking Coolant After Injector Replacement
I recently had my injectors changed at Ford and while I was driving it started dumping coolant. If the leak can be cause from the injector replacement or if they didn't put something back together right... 2005 f 350 6.0...
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2012 F350 - Reset CEL?
Is there a way to reset the CEL on a 2012 F350? I've tried unhooking the battery, but that didn't work. I know exactly what it is, one morning I was running late for work. And forgot to unplug my heater core plug. I know, I know, Just forgot about it when I was in a hurry. I just don't wanna pay the Ford house to reset it.
View 1 RepliesFord 6.7L Power Stroke Diesel :: 2012 F350 - Reduced Engine Power
The truck (2012 f350 6.7 lb cc 131,600 miles) started fine. Then while i was setting up the defrost i accidentally hit the ac button. Well I then hit it again to turn off. At that point the engine stalled. Which has never happened to me before. I started it back up which took a bit longer to get it to fire. It now says "Reduced engine power" and runs kinda rough. I thought well im at the end of my fuel filters life so why not change it since i had one. Well the. The FF housing broke. After replacement FF housing and filter it will no longer start. I took the filter back off and checked to see if it was cross threaded or sucking air. I checked that twice. Still no start cranks fast and strong. Codes are
P2138 something to do with the gas pedal
P0193 fuel rail sensor A high
P06A6 voltage on circuit A is whacky (paraphrasing here)
P0532 ac pressure sensor low
Ford 6.0L Power Stroke Diesel :: 2006 F350 - Coolant Disappearing Out Of Reservoir - White Smoke
Ok I bought a 2006 Ford F350 with 6.0 after driving for about 3 weeks I noticed a little bit of coolant was disappearing out of reservoir. So yesterday I was driving with a load Reservoir overflows replace coolant with one gallon of coolant and finish trip with no issues. I started truck today and it will not stop smoking it is also not overheating after hearing about head gaskets. I'm hoping it might be EGR cooler white smoke smells like raw diesel fuel. What to do?
View 3 Replies