Ford 6.0L Power Stroke Diesel :: Fuel Gauge Went To Empty Or Half With Full Tank
My fuel gauge acted pretty weird today. When I left my house today it was just above half a tank. I was sitting in traffic quite a bit and then looked down and it was below the e. I knew it wasn't empty so I kept going. Got to work. Went for lunch and it said full drove about 5 mins to eat and it went down to half a tank. What's going on? I am thinking of the fuel sender or wiring?
View 3 RepliesFord 7.3L Power Stroke (1999-2003) :: Erratic Fuel Gauge - Level Would Register Full When Only Half A Tank Or So
I've been having a very erratic fuel gauge issue as of about 2 months ago. My fuel level would register full, when in fact I knew it only had 1/2 a tank or so. Then 5 minutes later it would be pegged on full. Under a 1/2 tank the gauge would read any where from 1/2 to empty from 1 minute to the next. So last week I decided to drop my tank and take a look. I was thinking maybe my fuel sender was broken, maybe a loose wire in the tank, or even that my float had dropped off in to the tank.
After dropping the tank, I removed the PK-Up and sending unit and everything was intact. I placed my ohm meter on the sending unit and it checked out fine. So I took the Pk-up and rolled back up underneath the truck and plugged it back in. I had my son turn the key on and off while I moved the float to different levels in order that it would register. It registered empty, 1/4/, 1/2, 3/4 and full just fine as I moved the float to those levels. If you leave the key in the run position and move the float, it won't register or better said, the in cab gauge will not adjust with the movement.
You have to turn the key off move the float and hold it there, then have your assistant turn the key on and the gauge will show the position that you've moved and held it at. I simply removed the plastic cover from the sending unit, and sprayed it down real good with electrical contact cleaner. I didn't scrub the copper contact area at all.
I was concerned that scrubbing might remove more than I wanted to, and really mess things up. I attached an Ohm meter and checked resistance thru out the float travel. All checked out good and I reinstalled it. So now my fuel gauge is working as it should be. I did make a video while I ohmed the Sender Unit thru it's travel, but for some reason it won't load.
[URL] ....
Golf V R32 :: Fuel Gauge Sender Error - Going From Full To Empty To 3/4 Back To Current Level
My car is still at the dealer after having the recall done because they can't get the fuel gauge to start working after they performed the recall. But the gauge had nothing to do with the recall you might say. Correct. But prior to the recall being done the gauge was acting funny. Going from full to empty to 3/4 back to the current level.
I told the dealer about this and they looked into it as they were doing the recall. Now they said they replaced the fuel level sender unit, certain wiring connections but to no avail they still can't get it to work. So my question is, what is the type of Gremlin that could be causing this?
Ford 6.7L Power Stroke Diesel :: Fuel Gauge Is Showing Empty With About 45 Gallons In The Tank
The installation of the new 50 gal. Titan tank went well overall. Start up was smooth with no leaks but the fuel gauge is showing empty with about 45 gallons in the tank.
The sending unit was properly oriented ("clocked") so I'm guessing the electrical connector is not secure at the top of the sending unit. Not sure I can reach the connector without lowering the tank somewhat.
Ford 6.7L Power Stroke Diesel :: 2003 - Fuel Gauge Reads Empty Even After Filling?
Fuel gauge goes back to empty when I fill the truck all the way up. It goes back to full once I have used up 2 gallons ( from 36 gal to 34 ) on my 2012 F350. I also had a similar issues years ago with my 2003 6.0L .....
View 4 RepliesFord F-150 (2004-2008) :: Low Fuel Light Came On While Turning And Fuel Gauge Is Well Below Empty With Half Tank
I have a 2004 F150 XLT 5.4 L 79,000 miles. Yesterday i was driving home turned a corner and the low fuel light came on and the fuel gauge is well below empty. I had approx 1/2 tank of fuel when it happened. I have since filled tank all the way but the gauge will not move and low fuel light stays on. Everything else is working fine! I have never run the truck low enough on fuel to make the dummy light come on.....
View 5 RepliesFord 6.0L Power Stroke Diesel :: Fuel Pressure Gauge Dropped Down To 50 Then Back To 65 At 70 MPH
Well, I was cruising down the highway @70MPH and notice the fuel pressure gauge dropped down to 50 then back to 65. Kept watching the gauge and it would swing back and forth from 55 to 65.
Got off the highway. Nailed it at the light and watched the gauge drop to 53 and swing back to 65. Fuel pressure is not steady either. It swings back and forth from 52 to 65. Thinking the pump is on its her last legs? Truck got 194K on her.
Ford 6.0L Power Stroke Diesel :: 2005 - Fuel Level Back Light And Oil Pressure Gauge Out?
The backlight for my fuel level and oil pressure dash gauges are out. Would that require a simple bulb replacement or if there is something more difficult to replace, i.e. entire panel? The red needles illuminate, it's just the gauges themselves that are dark. The truck is my 05 Super Duty in the siggy.
View 3 RepliesPhaeton :: Fuel Gauge Goes To Empty When Gets To 3/4 Full
When my fuel gauge gets to 3/4s full it stops working and goes to empty. My range display also goes off. When I refill it works again until it reaches the same point.
View 5 RepliesFord Super Duty (1999-2016) :: Fuel Gauge Will Drop All The Way To Empty Then Go To Almost Full
I have an 03 f350 4x4 cc long bed and I seem to be having a problem with my fuel gauge. It doesn't show the true amount of what's in the tank and because of that I have run out of fuel a few times.
sometimes when I'm driving the light will come on and the gauge will drop all the way to empty then a little later it will go to almost full even with only putting 10 gals in the tank.
Any fix for this or do I need to replace the sending unit?
SC/SL/SW :: 2001 SL2 Not Starting And Fuel Gauge Reads Empty With More Than Half Tank Of Gas
My 01 sl2 wont start and the gauge says that the car is empty (before this problem, everything was working fine). I know that I have more than a half tank of gas, the car continuously turns over but wont start. I replaced the fuel pump and still it wont start (not to mention that the tank was more than half full at the time). I checked all the fuses and relays and everything seems fine. I am not even getting gas pumped to the filter.
View 9 RepliesFord 6.7L Power Stroke Diesel :: Exhaust Fluid Under Half Full At 2191 Miles?
New 2015 KR. Has 2191 miles on it so far, 69 engine hours and 21 idle hours.
Truck is telling me exhaust fluid is under half full. I thought a full tank of it was supposed to last around 7k miles???
Prius C :: Out Of Fuel But Gas Gauge Indicates Half Full
I recently took a drive down CA to visit some friends. The whole drive down, my gas gauge did not move one notch. Finally, when I got to SB, it had moved down a couple of notches. By a couple, I mean 2 at the most. The next day, we drive to Costco and all of the sudden my C stops and says problem with the hybrid system. My car had run out of gas however my gas gauge said I still had plenty over half full. This is partly my fault since I shouldn't have expected to have gone so far on the tank, but at the same time, why isn't my gas gauge warning me like a normal car would. I have an appointment to get the gas gauge fixed this weekend. My car has 4000 miles on it now.
View 7 RepliesSilverado :: 2000 Z71 - Fuel Gauge Swinging From Empty To Full And All In Between
I have a 2000 Silverado Z71 with the fuel gauge swinging from empty to full and all in between. I have heard of others doing this. I guess maybe its time for a new fuel module. It's been doing this for a couple of years, just keep putting it off. Is it easier to move the bed back or drop the gas tank? Also I have developed hard starting problems here lately, It having too crank extra long before it starts up. Could this be a sign the fuel pump is getting ready to go out.
View 8 RepliesGolf V R32 :: Fuel Gauge Reads Empty But Tank Is Full?
Full tank and the gauge reads empty. Has happened to me a few times. Occurs after a fillup and disappears after the car is left to sit for a while off. I would hate for this to happen on a long drive. Dealer hasn't been able to duplicate the issue. Am wondering if this might be related to the hiccup in some way. Also, am wondering if this is a fuse issue.
View 8 RepliesCamry :: Fuel Gauge Stuck On Half Full
I have a 2005 camry le the fuel gauge stuck on the full half.
View 2 RepliesPrius (Gen 1) :: Fuel Gauge Reads Full Bars Only When Tank Get Empty
I'm new to the Gen 1.
All has been well in just over a month of driving the car and about 3300 miles logged. The 12v, Aux battery was dead from the car sitting on the lot for so long (I replaced with a new OEM Toyota 12v battery) After a week of the car experiencing dim headlights, and various other electronics
No codes or CEL though.
Now that the 12v battery has been replaced, the car runs exceptionally well, aside from an intermittent fuel gauge issue where it only reads full bars (completely full) if I let the tank get to empty (Flashing single bar) or close to that. If I fill the tank from s
Chevrolet - Blazer :: 2000 - Fuel Gauge Flipping From Empty To Full
The fuel gauge on my 2000 Blazer is flipping from empty to full. (Even as I drive down the road it moves.) And nothing in between. The fuel pump was replaced about a year and a half ago. I've been told the fuel pump controls the fuel gauge. So I'm wondering if there could be a loose contection or if this is a sign the pump will go bad again.
View 6 RepliesPassat (B6) :: Low Fuel Light Came On And Gas Gauge Needle Went To Empty With Tank 3/4 Full
So yesterday I was driving home from work.. I know my tank was 3/4 full. All of a sudden, my low fuel light came on and my gas gauge needle went to empty.
The needle sits at E, but it still says about 20 miles till empty on the MFD. When I left the house this morning, it said 5miles till empty.. by the time I got to work, it said 20. Kinda odd..
I will hook up the vagcom when I get home tonight, any area I should scan for? or just a complete scan? There is no CEL error on the dash though. What I could look at to fix this?