Ford 6.0L Power Stroke Diesel :: 2004 F550 - Entire Bank Drops Out At Idle
I have a 2004 f-550 sd with a 6.0. I am having a problem with cyls, 2, 4, 6 and 8 dropping out at idle. if you rev the motor up they work fine. Could I have a bad injector oring? Seems that iap pressure is good. And seems funny that it is just the one side.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Got Code P0170 - Power Fuel Trim (Bank 1)
Drove the truck to the store tonight about 5 minutes away and everything seemed fine. Went to leave the parking lot and noticed the check engine light was on. Pulled out my tablet, dongle and fired up Torque Pro. Retrieved error code P0170. Truck has a little over 12,700 miles and is complete stock. I ran a search and didn't come up with much info on this code other than what Just Stroken posted in another post.
[URL]....
Looking for more information about this code?
Ford 6.0L Power Stroke Diesel :: Glow Plugs Failing On Right Bank
About a year or so ago, cyl 5 glow plug failed. 6 months later number 1 failed. Now number 3. I seem to remember someone mentioning that the module can sometimes cause produce similar problems. Are there two circuits in the module, one for the left and one for the right, or just one circuit for both? 167K on it so it doesn't surprise me that they fail but just odd that they are all on the same side.
View 5 RepliesFord Ranger / B-Series :: Metal Tinging Sound From Front End
I'm getting a high toned metal tinging sound (ting ting ting ting) from the front wheel that gets faster as I increase speed.
Shop said it's tire noise, but it's a distinctive metal sound like something rotating is hitting a thin piece of metal. It's quite loud, but I eventually don't hear it over 35mph because the vehicle moving is louder.
Eventually, around 35mph it's almost a constant tinging noise because I'm going fast.
2007 Level II, 5-speed.
Ford 6.0L Power Stroke Diesel :: 2004 - Loud Screening Sound - Starter Replacement?
after a loud screeching sound that sounded like a spun shaft rubbing on metal iwent under and found the starter wabbling around. Its going to be a first for me. Anything out of the ordinary i should know before moving on with the replacement..
04 f250 diesel 6.0
Ford 6.7L Power Stroke Diesel :: 2015 F550 - CEL Code Oxygen Sensor Performance Bank One Sensor One
The service truck threw a CEL, and i pulled oxygen sensor performance bank one sensor one code. That would be driver side sensor between the manifold and cat, rite? Don't want to change the wrong one...
View 11 RepliesFord 6.7L Power Stroke Diesel :: When Cold Diesel Engine Sound Intermittently?
It only happens on a very Rare occasion.
When Cold, and when I start out as I open the throttle, it suddenly sounds like there is not a piece of quieting stuff on the engine. I mean its like I can hear right into the engine itself.
I back off, It goes away then I dont hear it again for another Month or two.
Ford 6.7L Power Stroke Diesel :: Buzzing Sound While Running And A Much Louder Sound After It Shuts Off
Recently my brother in laws truck started making a buzzing sound while running and a much louder sound after it shuts off. Trying to track down the sound. Listen to the whole video because the end is where it gets loud.
6.7 powerstroke strange noise - YouTube
Ford 6.7L Power Stroke Diesel :: 2015 - Shaking Under Slight Load Due To A Small Incline And Loud Diesel Sound
So I have just over 14k on my 2015....... I love the truck but have had a few small issues. I had a water leak coming in from the roof that would leak through the grab handle. Nothing major dealer replaced one clearance light seal and they said the windshield needs to be re sealed.
Then I had a god awful irritating squeak in the dash..... It only does it late In the day when it's been hot. The dealer said it was a loose air bag. I have had the truck back a week and it's doing it again.
Those are little issues that will get resolved...... I hate having problems with a brand new vehicle but I understand it happens and that's what warranty is for.
I also reported a bad shake to the dealer...... The truck will shake very violently and have a very loud "diesel" sound. It's very specific at when it occurs. It has only done 4 times in the past 6 weeks including today. The odd thing is the 4 times it has done it has been the same time of day in the exact same spot on the exact same road!!!!
Basically I leave my office sit in some traffic and by the time I get to the parkway it has been35 minutes or so. Only happens in 6th at 60 which is roughly 1,400rpm a slight load due to a small incline and it shakes real bad! The typical "diesel" sound you get when under a load is very pronounced almost to a knock. It will continue to do this as you slowly increase throttle until it down shifts and then goes away. I also caught it doing it and I manually shifted to 5th and it went away.
Because of the rpm at which it happens with slight load only doing it in 6th I lean to a Trans issue and more so a converter problem. It feels like converter shutter. I just don't understand the engine sound.
I gave very descriptive info to the dealer..... Several techs drove it and could not duplicate. I just picked the truck back up last Thursday and the dash squeak is back and the shake happened yesterday and again today. So I am a bit irritated to say the least.
I really hate the fact that I know there is a problem but I also understand if a tech can't duplicate it he can't diagnose it. However today I did get a video of it with my phone so they will know I'm not making this crap up!
Ford 7.3L Power Stroke (1999-2003) :: No Power / One Bank Dead
I have a few codes I pulled with and AE Using CCT and I got codes PO263, P0269, PO275..
Also got P0603, P1316, P0470 on power train
Did a BUZZ TEST P0273 and also check uvc harness
I've replaced ICP,OIL and Filter,fuel filter,CPS still no luck.
Ford 6.0L Power Stroke Diesel :: White Smoke - Knocking Sound - Lost Power?
it's now 1,500 miles away on the side of the road.White smoke, knocking and lost power. Truck has 133,000 reman engine installed at 46,000. Is it common for hydro locking to bend a rod? He sent a video and it def sounds like a rod and degas is empty.
View 9 RepliesFord 6.0L Power Stroke Diesel :: Power Steering Pump Making A Loud Whining Sound
My power steering pump was making a loud whining sound. No problem, changed the pump. Now after the truck is started I will have no power steering or brake assist, give the truck a little gas and you can hear the power steering pump "start". I have tried every way to get the air out, or is that not the problem. I even lifted the front of the truck off the ground with a forklift and with the truck off turned the wheel about six times stop to stop. Fluid level looks good and has since adding after the change.
View 4 RepliesFord 6.0L Power Stroke Diesel :: Odd Whistle Sound When Going At 70 Mph
New to the 6 liter powerstroke recently upgraded from my 7.3. Recently this odd whistle sound started and I can't quite seem to fogure out the cause. At first it only happened if I was going 70 mph and now it will do it anytime it builds more than 15lbs of boost. I tried tightening some clamps and stuff but that did nothing.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Clunk Sound Going From R To P Or R To N
2003 6.0 FX4 w/ Auto Transmission, 180,000 miles
Last transmission service - unknown (I have owed the truck for 3,000 miles). I just acquired a clunking sound when shifting from R to P or R to N. No noise from N to D or lower or back up to D. It does not grind into gear, just clunks one time. It is rather loud.
All shifting while driving is normal, no slipping, or noise. This occurs on level ground, at operating temp, and +-650 RPMs.
Fluid level is okay. No strange odor. What will be the next steps to investigate?
Ford 6.0L Power Stroke Diesel :: 2004 - Runs Bad After Diesel 911 Injector Cleaner
I filled up at the same fuel station I've filled up at for 6 months, never had a problem. I just bought a 6 liter and put some injector cleaner in on the last fill up. Ever since then, it's been running really rough and missing when cold, and even when it's warm if I really lay into it, it'll pop and sputter. The fuel in water lights been on since I bought it. I think I have a bad sensor, because it was running fine until I put that cleaner in. Since its been running rough I put in new fuel filters and drained the fuel water separator, which only had fuel in it. I don't really know what it could be, but I'm 99% sure it's an injector issue since it started only after I put fuel treatment in.
View 8 RepliesFord 6.7L Power Stroke Diesel :: Clatter Sound Intermittently?
My truck will intermittently sound like an old 7.3 clattering away. It's done this for some time now. If I accelerate briskly it'll quiet down. When I first got it (used) it was quiet as a church mouse. It seems to normally be during the 1st 20min or so of a run. Weather and fuel doesn't seem to be a factor nor does it matter whether I have additive in the tank or not. My truck is a May '10 build 2011 with about 60k miles on it now.
Is this normal? Same 7.3 noise from the 6.7?
Ford 6.7L Power Stroke Diesel :: Humming Sound After Shutdown
My 2011 is making a strange humming sound after shutdown. It seems to be related to the normal waste gate sound. I have a video....
View 12 RepliesFord 6.7L Power Stroke Diesel :: Buzzing Sound After Shut Down?
Been noticing it more recently. After shutting truck down I would say 15-30 seconds after some type of pump or solenoid starts running and does so for another 30 seconds or so ( from the frontnofmthentruck). What this might be? Also have noticed it just once after starting I was walking around the front of the truck and heard this buzzing sound once again.
View 6 RepliesFord 6.0L Power Stroke Diesel :: Squealing Sound While Accelerating?
Back again.. I just replaced the HPOP and IPR valve on my truck a few weeks ago. While the turbo was out I cleaned it and applied a small amount of anti seize on the unison ring. When installing the turbo I had moved the y-pipe a little to get the turbo in place. About a week after it was running again I started to get a squealing noise under acceleration. The noise isn't a whistle like the turbo but an actual squeal. Its a little bit louder than the turbo whistle. If I am in park and rev the engine it doesn't happen. It only happens when I accelerate and seems to be when there is boost. If I let off the gas pedal the noise stops. I don't have an issue with making boost. I did replace the turbo boot when it was apart a few weeks ago so I don't think that is the problem I checked the y-pipe clamp and down-pipe clamp and both are fine. I replaced the serpentine belt this past weekend and checked all pulleys, they were all very good with no play. Another thing, the pitch of the noise seems to change with rpm's too. What could be causing this type of noise?
View 14 Replies