Ford F-150 - 1997-2003 :: 2001 - Fuel Gauge Doesn't Show Full?
I have a 2001 F150 Supercrew (5.4 V8, 2WD,Auto trans) and recently when we fill the gas tank, the fuel tank doesn't go all the way up to the "full" line. Don't know if this matters but: about a year 1/2 ago in a little town (while on vacation), we broke down and the trouble was the fuel pump. The little town did have a small auto-parts store, and luckily had the fuel pump we needed. Unfortunately we didn't have much as far as tools and we wound up tearing/cutting the filler hose and the vent line.
The little auto store did not have the correct rubber filler & vent hoses for my truck and would take a few days get in stock. We changed out the entire fuel pump and sender unit, and were able to modify some rubber hoses for a new filler & vent line hose. Everything worked great for a year 1/2 but in the last few weeks we have noticed that when we fill the tank, the gas gauge does not go all the way up to the "F" line to show full. With the price of gas, it is important to know exactly how much is really in the tank. Also, is there a battery in the ceiling console for the temperature and compass? Ours just stopped working yesterday.
Passat (B7) :: Fuel Gauge Not Reading Full After Fill Up
Having problems with the fuel indicator not reading full after a fill up. I have slowly filled my 2012 Passat TDI SEL till I can see diesel in the filler neck and the gauge still only shows 7/8 full?
View 9 RepliesFord - Explorer :: 1998 - Fuel Gauge Stuck At Full
I have noticed when I turn the key on the needle moves down just a touch but goes back to full. I have disconnected the wiring harness for the fuel tank and reconnected it. I have tried tracing the harness back towards the front but no luck yet. I'm guessing it's a bad ground or something. And if so what was the solution.
View 5 RepliesPassat (B7) :: How To Get The Computer To Show Fuel Economy For Full Tank
The computer apparently calculates the fuel economy per trip (or a series of trips if the car is stopped less than 2 hours) but I don't know how to get it to display the fuel economy for the tank full. Normally I'd reset the computer upon refilling but since it calculates per trip it doesn't calculate per tank. Fortunately the fuel gauge seems to be pretty accurate and each mark is approx 1 gal so I can do a quick approximation but I'm used to having the car do the tankful calculation. BTW, I reset on MFA 1, I've never reset on MFA 2 and that doesn't show tankful economy either.
View 3 RepliesFord - Explorer :: 2007 V8 - Check Engine Light On - Can Only Fill The Gas Tank About 3/4 Full
I have 2007 explorer 4.6 v8. The check engine light is on, and i can only fill the gas tank about 3/4 full, after moving the gas nozzle all around and taking about 15 minutes. I read a few different things while searching. Like vapor canister need to be replaced. or the vent hose needs to be replaced.
View 1 RepliesBuick - LeSabre :: 2003 - Fuel Gauge Needle Go To Full Then Drop / Way Down To Empty
I have a 2003 Buick LeSabre Limited, and everything was going fine with it till recently. The Fuel gauge started to go haywire as in the needle would go to full, then go back down to a Quarter, then back to 3/4, then drop all the way down to Empty, this is still occurring. At first I believed it to be the fuel level sensor, but then I started to notice something else.
A warning message came on stating that the oil level was too low, but when I checked the oil level it was fine, and last night when I was driving with the air conditioner on, I hit a bump and the air conditioner stopped working. I pushed the off button, and was successfully able to make the air conditioner to come back on with out having to restart the car.
The horn has also started to go in and out, and I do not know if they are all linked together by a type of computer or if they are separate.
Ford 7.3L Power Stroke (1999-2003) :: Fuel Gauge Goes To Beyond Full And Stays There
Two years ago I acquired a very very nice 2001 F350 DRW crew cab. The person I purchased it from put a Remanufactured 7.3 in it and set the truck up to pull wedge trailers. He put 25K miles on it and put it on Craig's list where I found it. It just turned over 300,000 miles.
One of the changes he made was to install a 70 gallon fuel tank in the frame rails below the bed. He told me that when the gauge reads EMPTY there is still 20 gallons in the tank. I remember him telling me that this anomaly is due to using the stock Ford pickup in the larger tank.
I have never filled the tank because so far the truck is used locally. I usually put 10 to 20 gallons in and when it gets to E I do the same fueling.
Then one day I turned the key on and the needle went up and beyond the full indication.
I can get under it and maybe the tank has some name or model number on it.
The truck runs fine, but the gauge concerns me. Eventually the truck will be making round trips from Chicago to our retirement home in Santa Fe, NM. It would be nice to have a working fuel gauge!
I have spoken to the person I purchased the truck from. He installed the tank as part of a complete upgrade that included a re-manufactured 7.3. The fuel tank is a 67 gallon Titan mounted between the frame rails. He believes that the original Ford sending unit was installed. That means it has 300,000 miles on it. I had the truck on a lift yesterday and it is a very tight fit. The garage said the best way to do the repair is to remove the bed. Six bolts, disconnect the tail lights and the 7 pin trailer connector and it is off.
So, my questions now are... Should I stay with a new Ford sending unit or are there better ones to install? Are there any other updates to the fuel delivery system that should or could be done at the time?
Ford 7.3L Power Stroke (1999-2003) :: Fuel Gauge Stuck On Full
Well besides the pyro breaking friday BEFORE live tuning,and the exhaust leak I gained on the way to Texas(not inpart of the pyro not working). Now the fuel gauge is stuck on full. It looks good,200+ miles and still on full. Could it be the gauge,or possibly just the sending unit? Maybe a fuse?
View 14 RepliesFord F-150 - 1997-2003 :: Fuel Gauge Malfunction - Jump Up All The Way To Full When Started
I have a 97' F-150 4.6 L and I've been having some fuel gauge issues.... I filled up my tank up and I drove it 130 miles and it still said full tank... even when I had 1/2 I would start it and every time I started it it would jump up all the way to full and slowly drop down. Then randomly last night it started working... I noticed as I hit rough patches in the road and bumps it would usually fluctuate, but it would also fluctuate up... It read I have 3/4 tank last night and I go to start it today and its back up to full! I don't understand... Wouldn't a bad sending unit just stop all together?
View 1 RepliesTouareg :: Faulty Fuel Readings / Show Full But Drops To 3/4 Of A Tank Within 10 Miles
Having trouble with the fuel level readings in their t-reg? When I fill mine up it shows as full but drops to 3/4 of a tank within 10 miles. Then it reads fine for about 300 or so miles and then drops to empty in about 20 or 30 miles. When I fill it back up it still has 6 or 7 gallons left. And yes, I am using 91 octane gas.
View 5 RepliesSanta Fe (CM - 2007-12) :: Fuel Smell In Cabin If Fill The Tank To Full
I have a 2007 Santa Fe. If I fill the tank to full, or close to full I will have a fuel smell in the car until the tank runs under 3/4. If I keep it under 3/4 I usally do not get the smell in the car.
The dealer could not figure it out and I still have this issue. It seems the smell is more in the front of the cabin then the rear. It just could seem that way since the smell is very strong. I have to park the car with the windows open.
There are no fuel leaks, no fuel on the ground, no drips, and the no spillage when I filled the tank.
Ford 7.3L Power Stroke (1999-2003) :: Erratic Fuel Gauge - Level Would Register Full When Only Half A Tank Or So
I've been having a very erratic fuel gauge issue as of about 2 months ago. My fuel level would register full, when in fact I knew it only had 1/2 a tank or so. Then 5 minutes later it would be pegged on full. Under a 1/2 tank the gauge would read any where from 1/2 to empty from 1 minute to the next. So last week I decided to drop my tank and take a look. I was thinking maybe my fuel sender was broken, maybe a loose wire in the tank, or even that my float had dropped off in to the tank.
After dropping the tank, I removed the PK-Up and sending unit and everything was intact. I placed my ohm meter on the sending unit and it checked out fine. So I took the Pk-up and rolled back up underneath the truck and plugged it back in. I had my son turn the key on and off while I moved the float to different levels in order that it would register. It registered empty, 1/4/, 1/2, 3/4 and full just fine as I moved the float to those levels. If you leave the key in the run position and move the float, it won't register or better said, the in cab gauge will not adjust with the movement.
You have to turn the key off move the float and hold it there, then have your assistant turn the key on and the gauge will show the position that you've moved and held it at. I simply removed the plastic cover from the sending unit, and sprayed it down real good with electrical contact cleaner. I didn't scrub the copper contact area at all.
I was concerned that scrubbing might remove more than I wanted to, and really mess things up. I attached an Ohm meter and checked resistance thru out the float travel. All checked out good and I reinstalled it. So now my fuel gauge is working as it should be. I did make a video while I ohmed the Sender Unit thru it's travel, but for some reason it won't load.
[URL] ....
Sonata NF (2006-10) :: 2009 - Gauge Will Show Empty When The Tank Has Fuel
I have a 2009 Sonata SE 3.3 with about 35,000miles. I am the second owner.
I believe that my gas gauge or the sending unit in the tank is bad. The gauge will show empty when the tank has fuel and then it will sometimes read normal.
Ford - Explorer :: Temp Gauge Rises And Falls After Thermostat Change And Radiator Drain And Fill
I did an engine swap for a junkyard motor my 4.0 ohv had a very bad rod bearing so I got one from the junkyard with 117,000,or so they say.Anyhow, after its all said and done it runs perfect except the temperature gauge seems to not get as high up on the gauge as before after sufficient driving(it used to run about middle of the gauge) it drops low at idle then goes up and stays up then goes down.it still has good heat, doesn't seem as good as before tho.I changed the thermostat also.
View 8 RepliesVenture :: Fuel Gauge - Reset Odometer At Every Gas Fill Up To Keep Track Of Mileage
I have an erratic fuel gauge. I have to reset odometer at every gas fill up to keep track of mileage. Need to replace the unit but I tried the GM Fuel treatment Plus in the gas tank first.
View 4 RepliesFord F-150 (2004-2008) :: 2007 - Fuel Gauge Rises Slowly After Fill
I have a 2007 F150 XLT with 150K Km. Recently the fuel gauge rises slowly ( 2 start up or 40 minutes of driving ) to the full mark after fill up. The truck is always fueled with Cheveron "regular" gas. What could be the problems ... float, sensor, fuel gauge? and how to check them?
View 13 RepliesFord Super Duty (1999-2016) :: Fuel Gauge Slow To Respond After Fill Up
Yesterday went to fill up ($4.05 a gallon geezz!) and noticed that after getting back into the cab, the fuel gauge still showed almost empty. So after yelling a few expletives, I looked again and noticed the gauge starting to make it's way up the dial. It took almost 30 min. before it showed almost full. I'm not sure what the problem is, as the gauge seems to still function. I don't drive the truck much as I use it as a tow vehicle. However, I do try and take it for a spin about 3-4 times a month just to exercise it. I was wondering if the fuel has started to gel and that is the reason for the slow fuel gauge response. Should I add a fuel conditioner/cleaner now that I have a full tank?
View 9 RepliesFord - Explorer :: 1997 - Fuel Fill Slow / It Keeps Clicking The Gas Pump Trigger Off
My '97 Explorer is struggling to take on fuel at fuel fill. Started all of a sudden...At gas station last week I inserted nozzle and attempted to fill tank as I normally do. It would not accept fuel at a fast pace. It keeps clicking the gas pump trigger off. I keep squeezing and it keep clicking of every 1-2 seconds!! What can this be? What steps can I take to analyze before I start replacing parts at random?
View 9 RepliesPrius C :: Out Of Fuel But Gas Gauge Indicates Half Full
I recently took a drive down CA to visit some friends. The whole drive down, my gas gauge did not move one notch. Finally, when I got to SB, it had moved down a couple of notches. By a couple, I mean 2 at the most. The next day, we drive to Costco and all of the sudden my C stops and says problem with the hybrid system. My car had run out of gas however my gas gauge said I still had plenty over half full. This is partly my fault since I shouldn't have expected to have gone so far on the tank, but at the same time, why isn't my gas gauge warning me like a normal car would. I have an appointment to get the gas gauge fixed this weekend. My car has 4000 miles on it now.
View 7 Replies