Elantra XD (2001-06) :: Gas Tank Will Only Fill About Half Way Before Clicking Off
At seemingly random times when I take my Elantra to the gas station it will only fill the tank about half way before clicking off. After doing some quick google searches I'm leaning towards something being wrong with CCV system. I read that over filling the tank can cause debris to clog the system and a few months back my father-in-law borrowed it he has a tendency to overfill the gas tank. But I've also read that there's an error code that tends to pop up with it and so far there's been none. Either way I'm not familiar with how the CCV and related systems work.
View 3 RepliesElantra XD (2001-06) :: Cannot Fill Fuel Tank / Gas Overflows When Filling
I have an 04 Elantra GT. My gas gauge is showing full but the car is running out of gas. I try to fill the tank and I get the annoying click and after trying for a few, gas comes up the filler and overflow tube and makes a mess. At the same time, I was getting a P0449 code. I got an evap canister from the junkyard and that seems to have gone away.
Tried diagnosis but dropping the fuel tank to access the lines. When I jack the tank back up into position, you can hear gurgling sounds and as if the gas is coming up the fill tube. I also opened the access panel under the seat to see the pump assembly and when I removed the 8mm bolts, gas came pouring out. There was definitively gas in there. Checked the float on the pump assembly and it moved?
There is also something at the fuel neck at the top. Don't know what it is and if that could also be part of the problem.
Elantra XD (2001-06) :: After Fill Up Car Will Occasionally Sputter Or Sometimes Stall During Idle
I just picked up this 2005 Elantra last month. She runs GREAT - except after filling. Then she will occasionally sputter or sometimes stall during idle. Otherwise, if tank is below 3/4 (approximately), she runs fine.
View 7 RepliesElantra XD (2001-06) :: Gas Vapor Lock At Pump Won't Fill Tank
Son was unable to fill his car's gas tank, 2002 Elantra (but happens to all cars sometimes).
The vapor lock on the pump kept shutting the gas flow off.
This was caused by the tanks vapor exhaust being unable to exit while filling, so the only place to go was back up through the gas fill hole.
The charcoal filter had sprung a leak so the zillions of tiny little charcoal pellets pour from the filter into the rubber hose clogging it.
The Filter is $150 at Hyundai. Not available at AutoZone or OReilys.
Very simple to replace a couple bolts a few hose clamps.
Strange problem, thats no one at work had encoutnered before. A few Hyundai mechanics had heard of it and worked it before.
Also could be Purge Valve or Vent Valve solenoids...search EAP system too if your having this issue of not being able to fill your tank with gas, without 500000 vapor locks shutting the pump off!
Elantra XD (2001-06) :: Cylinder 2 Misfire / Rough Idle Especially After Fill Ups
I have a 2001 Elantra with 170K miles. well taken care of. I've been having a rough idle issue for some time now. The car idles very rough. I checked for codes and I got the cylinder 2 misfire code (P0302)...
I started out and replaced the plugs and wires, no solution...
I replaced the coil packs, no solution...
I replaced the MAP sensor, no solution...
I figured it may be no to low compression, so I did a compression test and all cylinders came back normal, still no solution...
I figured it might be a dirty injector, so I poured some seafoam in the gas tank, and no solution...
So my next step is to switch out the injector. Is there anything I am overlooking?
Here's the big thing that is happening too... Everytime I fill up the gas tank, I turn the car on and it idles even rougher. Like if you talk while sitting in the car, you sound like Chevy Chase when he is on the vibrating bed with Beverly D'Angelo in the movie vacation! LOL. It slowly goes away after 10-15 minutes of driving. All this rough running engine ONLY happens at idle, otherwise it runs very smoothly.
Elantra XD (2001-06) :: 2002 HYD - Engine Misses Sporadically Often Every Time After Fill Up
My daughters 2002 HYD Elantra engines misses sporadically often every time after a fill up. What it might be. Once some of the gas is used then it stops.
View 3 RepliesElantra XD (2001-06) :: Strong Gas Smell After Fill Up - Codes PO455 And P2251
I have no problems pumping gas in, but the entire car cabin smells very strongly of gas after filling up. It seems to come from the area of the charcoal canister. No dripping of gas, no puddles... Did a smoke test, no leaks showed up anywhere (according to the mechanic). I do not want to start throwing parts at this to fix it - where should I start, and in what order should I throw parts? 2003 elantra GT sedan, 70k ....
View 1 RepliesElantra XD (2001-06) :: 2002 - Hard Start / Bad Gas Mileage And Early Fill Up Click Off
I am trying to fix the pesky hard start that I have. My car doesn't start right up anymore unless it is frozen cold. Other than that it takes 2-3 cranks sometimes 4 to turn over. That's annoying and embarrassing and I am trying to remedy it ASAP.
I have a check valve and Purge valve on hand right now. In my research it seems this is where I need to focus. I do have an engine code it was P0456 this time. I also have a gas cap.
I have a check valve because of the all too familiar cutting off early at fuel pump problem. I wanted to start there first since I am sure something needs repairing down by the fuel tank and since the problem is common. And hopefully the valve will work with the fill up and MAYBE with the start, if not that is where the purge valve comes in.
I got as far as get the 2 12mm bolts off and then couldn't make it any further.
Elantra XD (2001-06) :: Stalling After Filling Up With Gas
Hyundai Elantra 2003 ( 140000 KMs) Okay has happened the last 2 times, after putting gas in car. When I turn the key, engine revs up pretty high, about 3000 rpm and then car stalls. Will happen 2 or three times but does start if I give it some gas...
View 2 RepliesElantra XD (2001-06) :: Stalling When Try To Move The Car Or Step On The Throttle
I can get it started and let it idle for an hour....idles smoothe. As soon as I try to move the car or step on the throttle...it stalls.
View 2 RepliesElantra XD (2001-06) :: Stalling Randomly At Stop Lights / Low RPMs
2001 hyundai elantra. Car is almost stalling randomly at stop lights. Low rpms under 500 and stops. Sometimes drops to 100 rpms then shoots up to 500 right before it might stall. Engine light came up got misfire on cylinder 2 and 4 with codes p0440 and u0d00.
View 5 RepliesElantra XD (2001-06) :: Stalling / Power Loss And Car Would Jump Gears
Almost two weeks ago, I began to have a problem with my car. (2001 Elantra) At times it acted like it was about to stall as I was driving up the smallest incline. Once I got up the incline, my car would jump gears. (second to third, so on)...
The car was taken to Advanced Auto where I received codes about the catalytic converter and the output sensor. I've known about the converter since I bought the car last year and the sensor was replaced. But I am still having problems with the car. My friend is literally having to drive it like it was a stick.
We fear it might be the transmission as I you can go in reverse with no problem. What it could be instead of the transmission?
Elantra XD (2001-06) :: 2003 - Stalling While Driving And Won't Respond To Gas Pedal
I have a 2003 elantra with 90 k when I'm. Driving the car it just stalls out the car never turns off it just idles and won't respond to gas pedal. I have to put the car in neutral accelerate and drop back to drive to keep driving it. Happens at all times car at normal heat , at regular driving speeds in the street any.
View 5 RepliesElantra XD (2001-06) :: Code P1166 After New Alternator Installed And Stalling
Code P1166 showed up after I have new alternator installed from coolant leaking onto it. I dont think that is the cause though. In the fall I found some acorns in the air box and just recently in the heater fan. In December, after the acorns were found, the car had a low idle a seized alternator and a broken belt.
No acorns are in the air box anymore, or in the heater fan. Car has more of an erratic idle and stalls now that it is parked on an incline.
Elantra XD (2001-06) :: 2.0L Misfiring / Subsequent Stalling When Stopped At Intersections
My 06 Elantra started to stall / misfire when I was driving it. It doesn't seem to matter how fast I am traveling as it will " misfire" for lack of a better word. It has an automatic transmission, and the rpm's will start to bounce as the car begins to jerk when this occurs.
I don't live anywhere near a dealership, so I brought it to the garage that I take my other vehicles to, and they had a hard time diagnosing the problem due to the fact that there never was an error code coming up or check engine light. They ended up finding a bad coil and changed it out.
That was 2 months ago and I haven't had a problem with it till today when the exact same issues resurfaced. And again no check engine light comes up, just the misfiring and when stopped at intersections, subsequent stalling.
Elantra XD (2001-06) :: Hesitation And Stalling - Gas Pedal Suddenly Unresponsive
I have a 2001 Elantra with 126k miles. For months it's been randomly hesitating, meaning I'll be riding along and suddenly the gas pedal will do nothing...then about 3 seconds later, VROOOM, the gas pedal will start working again. Recently, it's started stalling as well.
I've already replaced the MAP sensor, input speed sensor, throttle position sensor, spark plugs, wires, and coil pack. Nothing has worked, but it is getting progressively worse (it stalls more frequently, and the gas pedal becomes suddenly unresponsive more often).
Elantra XD (2001-06) :: 2003 - Stalling / Loss Of Power When Idle And Press The Gas To Go
I got a problem with my 03 elantra, recently the car had a problem of stalling. I replaced the crank shaft sensor and that fix the problem, but the car always when idle and then press the gas to go feels like it has no power at all then all the sudden all power kicks in it only does that for a second when i press the gas. What I did was to replace the fuel filter that actually was extremely dirty,but no change i guess it could be the fuel pressure regulator.
View 10 RepliesHyundai - Elantra :: 2000 - Gas Tank Won't Fill
Like a lot of others, my 2000 Elantra will just barely take gas at the pump. So I've done the research, I think I understand the problem, but when I tried to find the replacement filter, there seem to be 4 different parts ranging from $8 to $180. Which part should I order and order first, or should I just replace them all?
View 4 RepliesElantra MD (2010-15) :: 2012 - Gas Fill Up Cut Off Shortly After Start
At many, but not all, gas stations, as I try to fill up the gass flow cuts off very shortly after I start. No matter how I position the nozzle it cuts off. if I squeeze the trigger just barely so the gas flows slowly, then it will remain on, but takes forever to fill up.
Again, doesn't happen at every gas station, but a lot. Based on that, I'd assume it's not a malfunction in a valve, filler neck, evap canister, etc.