Elantra XD (2001-06) :: Noisy Flex Pipe Exhaust
How to replace this bad flex pipe....
View 25 RepliesElantra XD (2001-06) :: Exhaust Leak Between Front Cat And Connecting Pipe
I changed my front catalytic converter yesterday. Everything was installed properly and the repair went smooth. Unfortunately when I started the car, I discovered the connection between the bottom of the cat and the connecting pipe was leaking out a ton of exhaust. The previous cat didn't leak like that. I put in a new gasket and tightened the bolts extra tight but the leak is still there. The worst part is that the leaking exhaust fumes are all traveling up into the hood, which makes it look like the engine is smoking. What should I do to stop the leak? I even tried using muffler tape but that only worked for an hour until it hardened and sounded like crap.
View 3 RepliesElantra XD (2001-06) :: 2005 - Coolant Leaking Externally From The Head Gasket
Our 05 Elantra (170k miles) is leaking coolant externally from the head gasket. At first I thought it was coming from the freeze plugs, but it's actually leaking from above. I'm mechanically inclined but have no experience with head gaskets. I have access to Alldata but no service manual. Will it tell me everything I need to know? The farthest I've gone inside an engine is removing valve covers car runs great and we like it enough to want to keep it for a while ... I'll also mention I will be replacing the timing belt as well.
View 7 RepliesCivic - Honda :: 1998 - Liquid Leaking Between Exhaust Pipe And Muffler
I noticed liquid leaking from the area between the B exhaust pipe and the muffler. The B exhaust pipe is simply the long exhaust pipe that attaches to the A pipe, or center exhaust pipe near the front. I think the leak is water. It's a slow leak/drip that appears to be coming from the gasket. I have a 1.6L 1998 Honda Civic DX.
View 6 RepliesIsuzu - Trooper :: Overheating - Coolant Is Coming Out Of Exhaust Pipe
I own a 2001 isuzi trooper, the water pipe has been broken a couple times, so the radiator has been leaking so my car overheats. But I fixed it a couple of months ago, yet after I fixed it the car kept going through the water/coolant extremely fast and was overheating unless i put water in it every other day.
Yet, a couple of days ago, I was driving home, and i heard a bubbling noise, ignoring it i kept driving only to have complete loss of my accelerator and had my car rolling along the highway unable to accelerate. (And the last time I put water in the radiator was 10 days ago) now my car won't even turn on, and it sounds like it is having a very difficult time when I try the ignition. plus when I do try to turn the engine on, coolant is coming out of my exhaust pipe.
Ford 7.3L Power Stroke (1999-2003) :: Oil Leaking From Driver Side Exhaust Manifold At Junction With Up-Pipe
I had a fuel starvation problem because Ford painted the inside of the fuel tank and the paint was coming off and clogging the filters and because I foolishly drove it I now have white smoke spewing out of the tail pipe and an engine miss.
I also explained that I thought that the white smoke did not smell sweet like antifreeze, but rather like diesel. (Hoping that a head gasket replacement is not required.)
I am in the middle of doing the Hutch Mod with frame-mounted Racor PS120-2 jar-type screen pre-pump filter and shortening my previous Harpoon Mod and paint stripping and powerwashing the inside of my tank. Next I plan to move on toward the engine issue.
This evening I was under the van with a flashlight and I noticed that there was a black liquid of some sort at the driver's side exhaust manifold where it joins the up-pipe. At first I was afraid to touch it fearing that it would be carbon-sooted water, but it felt and tasted like carbon-sooted diesel.
And since I haven't started the engine in two weeks and it has been routinely near or over 100F in Sacramento, water would have likely evaporated days ago.
Does it make sense if the fuel starvation problem caused an injector nozzle or its cup to crack or to stick open or to otherwise spew unburnt fuel into the exhaust manifold which would cause the white smoke? Obviously, the unburnt fuel must get from the affected cylinder(s) to the tail pipe somehow, which likely means out the exhaust valve, through the exhaust manifold to the up-pipe and through the turbo to the exhaust pipe and finally to the tail pipe.
See pictures at my CP. I can't figure out how to attach them or put them inline here because it still says I can't do attachments.
What is my next move? Remove the driver's side valve cover? If so, what should I look for, etc.?
2002 E350 extended body van 7.3 diesel auto trans converted to 4x4 (bought new)
Ford - Windstar :: Small Metal Tube Is Leaking Coolant?
1999 Ford Windstar started overheating. I discovered coolant leaking from a small metal tube coming out the top of the rear right (drivers side) of the engine. There are two similar small tubes. This one appears to be corroded through. I tried to pull it off, but if felt like it would break off.It's pretty far back and somewhat difficult to access. I'm wondering if this can easily be replaced and if so, how would I go about it.
View 7 RepliesElantra MD (2010-15) :: Rattle In The Undercarriage - Exhaust Resonator Pipe Replacement?
I had my E in for service today to get her fluids changed and to replace her engine oil with Synthetic finally (second service for her).
I had noticed a rattle in the undercarriage for a few weeks now and assumed it was a common TSB for a heat shield that rattles. As it turns out, it is the resonator pipe that needs to be replaced (under warranty). I've never had to replace one before so hopefully it's just a one-off!
Otherwise, I can already tell she's happy to be filled with some wonderful Synthetic...
Ford Super Duty (1999-2016) :: Leaking Coolant From Pipe On Driver Side
I think I have a clamp or something loose as i am dripping coolant from a black and silver hose/pipe on teh drivers side of the motor.
I can't see any clamps, well clamps i can recognize. how is this black pipe connected to the aluminum pipe? at that seam is where it's leaking.
Elantra MD (2010-15) :: Exhaust Pipe Blows White / Gray Smoke When Accelerating
My Elantra is at 14k miles and it has happened twice now that the pipe has released white/grayish smoke when accelerating abruptly (pretty much forcing the engine) on the highway above 60mph. I can see in my mirror that it leaves a pretty big smoke screen behind me.
I took it for an inspection after the first time it happened and the mechanic said it might have just been steam and that I should not worry about it. Since my 15k maintenance check is coming up, I will ask that they actually check on it.
I'm also curious to know if this could cause me to get a ticket? I'm thinking I could get pulled over for "imparing the vision of drivers behind me and making it dangerous for them", or something like that.
Ford Super Duty (1999-2016) :: 2001 F250 5.4L - Smoke From Exhaust Pipe
2001 F250 5.4L - I recently had my muffler changed and the pipe flange on the tailpipe up by the exhaust manifold welded back on. I haven't driven my truck much this past summer so when I took it in to get the muffler fixed the front caliper got temporarily stuck like it tends to do. It eventually freed up but in the meantime I noticed a hot oil-like smell coming from my truck from time to time. I chalked it up to either the new muffler or maybe it just smelled hot and it was instead the front brake caliper still being stuck. One day I'm driving down the interstate and I start uphill. I noticed smoke behind me and pulled over. The brake was not overheating so I got underneath the truck.
The smoke was rolling off of the exhaust pipe all the way down it all the way up near the manifold but mostly around the muffler. The smoke quickly went away while I was under the truck. I noticed it doing this only while the engine is under a load like going uphill. Just driving around town nothing is noticeable. When it does smoke I lose power. Once I slow down for awhile and then gradually speed back up things seem okay. I checked the oil.
Normally I don't lose a drop but this time I was a quart low but the oil on the stick was clean. It's been awhile since I had my oil changed but very little mileage on this change (my truck has sat awhile). My truck doesn't leave a drop of oil under it when it sits. From what I read you can remove the radiator cap and start the truck to see if it's a blown head gasket. At least that one of the things I can check easily without actually taking the plugs out even though the oil looks clean. The radiator has not lost any fluid. The transmission fluid is also good. It's been doing this for about 3 weeks.
I still drive it to and from work (about 15 miles round trip) everyday but I take it easy on the acceleration and stay on city streets. I looked into the EGR system online for my truck and instead found an EVAP purge solenoid/valve in its place on the passenger side. I don't have any service lights on the dash. I went to Autozone and had them scan it but nothing came up. I read somewhere that either the purge solenoid assembly or EGR (I can't remember) can burn up the board if it goes bad resulting in no code showing up.
I recently changed a vacuum valve out that went bad that controlled the vacuum chamber used to operate the hubs on the 4WD. The 4WD is now operational again. Assuming the head gasket is not blown, what to check for next?
Ford - Taurus :: 1993 - Exhaust Clamp Between Resonator And Exhaust Pipe Came Off
I have a 93 ford taurus 3.8L V6 automatic GL. The exhaust clamp between the resonator and exhaust pipe came off and I need to know what size clamp I will need to replace it. I think it is a 2 inch but I am not sure.
View 1 RepliesFord Exhaust System :: Exhaust Pipe Cut Just Behind The Rear Of Cab - No Muffler
i have my 4 inch exhaust pipe cut just behind the rear of the cab right now with no muffler. If i cut it further up maybe jsut under the front seat or so what would this to the sound? would it make it deeper or louder?
View 7 RepliesFord Exhaust :: Crack And Subsequent Leak In Exhaust Pipe
Actually developed a crack and subsequent leak in a pipe running lengthwise, so assume the factory weld over the years went bad. Since it would be a weld overhead, wonder what method would be best? Would oxy acetylene work or mig? I don't have a tig so that not an option for me.
View 2 RepliesElantra XD (2001-06) :: Metal Grinding / Chugging Noise
I have a 2006 Elantra 4 cylinder with only 55,000 miles put on it.
Whenever I accelerate I hear this noise that sounds like a lawn lower under my hood, usually only there until around 45 MPH, then it dies down a bit. It as been getting louder and more....... screechy..... as of late.
Also, when idle, there is a sound that almost sounds like a metal grinding chugging noise. It comes and goes with no real rhythm or timing.
Additionally, there is a metal grinding noise coming from what seems to be my front right wheel area when I make wide right turns, as well as intermittently while driving regularly.
To my knowledge, neither of the motion noises seem to be happening above 45-55 MPH, or they are too soft to hear at those speeds.
Elantra MD (2010-15) :: HVAC Blower Noise / Metal On Metal Rubbing
My Elantra's HVAC fan has always been a quiet thing, even on 3.....we won't mention level 4 and the fact it sounds like a 747 at takeoff.
I kid you not, the very evening I hit 60,000 miles and the general warranty expired, the blower motor started making noise like it was throwing a bearing and definitely sounded like some light metal-on-metal rubbing. After I became irritated at this, the noise went away and didn't come back until just a few weeks ago. I could make it stop by smacking on the bottom of the fan assembly a few times but I want a more permanent solution.
Tonight I dropped the blower out which was stupid easy except for the fact you're upside down in the dark with your head in a hole. But three screws and an electrical connector later, I dropped the assembly to find no serviceable components. I mentioned this to friend of mine who's into Volvos suggested spraying some lithium grease on the hub of the blower and letting it run long enough to quiet it down. I'll do this over the next few days and report back but part of me thinks a new blower may be in my future.
GMC - Sierra :: 2004 - Blowing White Smoke From Tail Pipe And Coolant Consumption
I have a 2004 GMC Sierra 2500 Duramax diesel pickup. It has been blowing white smoke from the tail pipe and drinking coolant, 10 - 15 gallons since February. There are no obvious leaks of coolant under the truck. However, within the last 3 weeks it has on 4 occasions spewed coolant from the surge tank from the overflow vent. We have narrowed down the problem to either a headgasket leak or an injector leak.
We had it in to the dealership (big mistake) and they found nothing wrong. They think we either need to wait for something catastrophic to happen or do the head gasket and replace the heads. There is a technical service bulletin about the head gasket. There is anecdotal info from an article written by a master tech from GM about the injectors. We also know there is something about GM paying for the injectors and injector sleeves to be replaced if there is an issue like we have.
All the dealership is saying they did was drive around the truck and saw no coolant spewing forth and no smoke. They did see a lowering of coolant level in the surge tank. They also did another pressure test on the coolant system and found nothing. Outside temps and weather conditions have no effect on this situation unfortunately nor does the length of time it's driven. How much should a head gasket/head job cost? How much time should it take? Does it require removal of the cab? How much should an injector job cost? How much time should that take?
Elantra MD (2010-15) :: Metal On Metal Noise When First Accelerating
I have a 2012 Elantra with 21000 miles on it. It runs well but in the last month or so it has started to make a strange noise when first accelerating. I would describe the noise as touching a fork to a metal fan...kind a "zzziiiinnnkkkk" sound, I guess. It only happens when the car has been sitting for a while and only on the first acceleration, usually in first, second, and third gear after which it immediately goes away and doesn't happen again until the next time we drive it. It seems like it would be related to the transmission except the sound is too tinny for it to be the gears. It sounds more like sheet metal making that sound. I took it to the dealer but they said they couldn't make it make the sound, which is crazy because it does it EVERY time we drive it.
View 14 RepliesHyundai - Elantra - Gaskets :: White Smoke Coming Out Of Exhaust / Radiator Fluid Is Leaking Into Engine
I'm pretty sure I have a blown head gasket. I have white smoke coming out of exhaust and the oil is brownish in color indicating radiator fluid is leaking into engine. The car has over 200K on it. I purchased Steel Seal. The guy I talked to from Steel Seal said if radiator fluid is dirty (which it is)than I should flush radiator before using product. I don't have money to replace the gasket and I don't have money for a new car right now. Can this be a fix that gets me through a couple months?
View 3 Replies