Caravan/Voyager :: Power Steering Pump Not In Line 2000 Grand 3.3?
I had a VERY bad leak, to the point where I would fill it, an hour later it all leaked out. I had a mechanic work on it, and he rebuilt the PS pump, BUT the pulley was cracked, they DON'T make that size anymore. He put a bigger one on, only to find out, it was rubbing on my brake lines so I couldn't drive it! SO I had another grease monkey work on it, went through a few new pulley's FINALLY found one! BUT went through 4 Serpentine belts!!
After 3 months with NO VEHICLE, we finally got it all back together. BUT now it is not all lining up we couldn't tell until we had the belt on. it is about a 1/4 of an inch to much to the right.
I'm thinking maybe washers or spacers would work?
Lexus LS 2007+ :: Steering Wheel Temporarily Off Center After Sudden U-turn
While driving to work I did a quick U-turn to avoid a congested left turn lane and when I completed the turn and straightened out, the steering wheel was about 30 degrees off center when driving straight ahead. A few seconds later it slowly centered itself, I'm assuming this was a Variable Gear Ratio Steering (VGRS) fault.
View 5 RepliesCaravan/Voyager :: Steering Wheel Shakes And Pulsates When Put On Brakes
When i put on the brakes the steering wheel shakes and pulsates. Iam getting mixed info. One person I know said it is the brakes (front), another person said i need the alignment checked. yet another said Rotors, and still another said back brakes.... When i touch the brakes the whole van pulsates and the steering wheel shakes.
View 3 RepliesCaravan/Voyager :: Airbag Light Goes On And Off - Clock Spring Breaking In Steering Column
I drive a 2000 Grand Voyager with 260,000 miles on it. The airbag light goes on and off and I was told the clock spring is breaking in the steering column. Is there any danger to not having it fixed besides the airbag not going off when it is supposed to, like airbag going off when it is NOT supposed to or function damage to the car or electrical systems. I have mechanics tell me both yes and no. Any thoughts from people here? I'm trying to get as many miles out of it as possible without spending too much on stuff that doesn't need fixed.
View 10 RepliesCaravan/Voyager :: Front Brake Caliper Frozen And Cannot Turn The Tire
My right front brake caliper is frozen and I cannot turn the tire. This happened about a month ago and I went to Autozone and they gave me a new caliper, rotor and brakes, under warranty, and now the caliper is frozen again and I cannot turn the tire when jacked up. It seems to release after a period of time. I am not sure if it has a proportioning valve for the front brakes, but the driver side wheel turns freely and is not stuck.
View 2 RepliesCaravan/Voyager :: Turn Signal Works Occasionally - Sometimes Starts Then Freezes
We have a 96 t&c. The turn signals only work once in a while. Sometimes they start to work and then freeze. Sometimes they don't work at the beginning of a ride and start to work 10 minutes into it. It seems quite random.
View 14 RepliesCaravan/Voyager :: 07 SXT - Radio And Clock Shuts Off And Will Not Turn Back On While Driving
2007 Grand Caravan SXT, 86K Miles
Factory Radio Clock, AM/FM, CD and Tape Player.
Radio and Clock looses power and completely shuts off and will not turn back on while driving. Miles driven does not seem to be consistent.
All other Electrical seems to work fine, overhead console, Wipers, Blower, Turn Signals, Head Lights, Instrument Panel all seems fine.
When car is shut off, Blower continues to run for a few seconds and then stops.
When car is restarted Radio/Clock magically comes back, clock is reset to 12:00 and radio is on AM.
Get some funny flashing of Idiot lights on cluster that to my recolection is not normal behavior. Once while my wife was driving it the Vehicle Theft Alarm Light came on when she started it up and it stayed on until she stopped and then started it back up when she left the store she was at. That has only happened once.
I checked the Battery Voltage while running and stopped and all seems normal. The Battery was new this December. I also checked fuses and there are none that are blown.
Caravan/Voyager :: 1999 Engine Won't Crank Or Turn Over Just Some Clicking Near Relay Box
Intermittent problem, occurred 4 times during past 4 weeks, always during wet/rainy/damp weather. Three times when car was sitting overnight, once at work in parking lot after a 12 hour work shift. Each time, the engine started 5 or 6 times then died like someone turned the key off two seconds after the engine started. Then the engine would not crank or turn over, just some clicking near the relay box under the hood. Lights, power windows, etc. all work fine. Battery voltage OK. Jump starting or battery charger makes no difference. Note: With key in "run" position, no display to odometer though all idiot lights light up like normal.
1st time, after about 15-20 minutes, car started. 2nd time, towed to my mechanic (who thought security system lock out) then a second tow to dealer. Dealer found power into power distribution center but none out. Replaced PDC. Car worked fine for 1 week. Same problem twice since repair. First post repair failure I had van re-towed to dealer. Of course, it started for them. Left overnight 2 more nights. Started for them every time. They say it is a "problem with computers" but they don't know exactly what. They also say the Alarm set Dash light is coming on with the rest of the dash lights and that is a no-no. 2nd post repair failure happened this morning. Tried locking door to reset alarm. No change. Locked doors, opened rear hatch. Lights flashed but horn did not sound. When car is working and I do that (open hatch with other doors locked), in addition to lights flashing, horn beeps! I also disconnected the positive battery terminal, waited 10 minutes, reconnected and attempted restart. No change. Car still won't start and odometer display does not work.
Van has 110,000 miles. Otherwise in fantastic shape and runs great (though only gets about 20MPG). Owned van for 2 months and have driven about 7,000 miles. 1st problem I've encountered (other than a very uncomfortable drivers seat - feels like a spring is sprung!)
Caravan/Voyager :: Catalytic Converter Getting Red Hot And No Power?
Someone put sugar in my gas tank so I had it worked on at the Dodge place they replaced my fuel pump..fuel filter cleaned the tank..flushed the lines cleaned my injectors and replaced the plugs..I went to pick it up I barely made it a mile down the road I had no power and a lady flagged me down to tell me to pull over because I had sparks coming from the bottom of my van I looked under the van and the catalytic converter was red like hit coals the Dodge place is telling me its my flex plate? I think they are misdiagnosing the issue because before the sugar issue I had no problems with my van?
View 14 RepliesCamry :: 2010 LE Power Steering Fluid Overflow - Steering Very Tight At Low / Parking Speeds
2010 camry LE
A family member did a tune up on the car and did not realize that the power steering reservoir had a HOT and COLD min/max lines. He filled up to the max line for HOT while the car was completely cold. He also filled up with Prestone Power Steering fluid with Stop Leak instead of ATF/DEXIII.
The car was driven a few times for maybe 50 miles in total before I found out about all this and I drained the fluid out to the appropriate levels. However the steering at low/parking speeds is still very tight (tighter than what I used to remember, at least).
Did he royally screw up the power steering system here? What can I do?
Caravan/Voyager :: 1990 V6 - No Power To The Fuel Pump?
I have 1990 dodge caravan v6, i checked to see if i got power to the fuel pump and there no power going
View 4 RepliesChevrolet - TrailBlazer :: 2003 - Tight Steering / Hard To Turn Wheel
Having trouble turning my wheel both ways on my trail blazer. Just replaced wheel bearings on truck not sure what would causing this. Also tries are wearing down..
View 6 RepliesCaravan/Voyager :: 98 - Power Locks Keeping Locking Every 30 Seconds When Off
When it is off, the power locks keep locking every 30 seconds!
View 4 RepliesFord Excursion :: Steering Loose While Cruising Then Feels Tight When Straighten Out After A Turn
The steering on my Ex isn't working like it should. At times it feels loose when cruising then feels tight when straightening back out after a turn... the wander is really bad...
My PS fluid is also turning into a muddy brown goo every 5k... I changed the PS pump this summer with a supposedly good used one...
What should I be looking at/checking for?
Caravan/Voyager :: 2000 - Power Lock Switches Aren't Working
I have a 2000 Dodge Caravan. The power lock switches are no longer working (both driver and front passenger). They worked fine the last time I drove the vehicle and both switches stopped working at the same time. The power locks themselves still function with the remote and still lock when speed reaches 25km. Just the actual switches on the doors are not functioning.
View 5 RepliesTouareg :: Shuddering When Turn The Steering Wheel Full Lock Left Or Right In Tight Places
I have a problem with my VW Touareg 05 plate. When I turn the steering wheel full lock left or right in tight places the car shudders. It doesn't do it all the time but does appear to be getting worse as time goes on. I have been told that it may well be the Stepper motor.
View 9 RepliesCaravan/Voyager :: 1996 SE / Turn Wipers On And Motor Growls But Wipers Do Not Move?
Turn wipers on and motor growls but wipers do not move, checked 30 amp fuse and it is good, all other functions of the multifunction switch are good.
View 2 RepliesCaravan/Voyager :: 1994 Vehicle Stops / Sputters To No Power - Could Be Vapor Lock?
I have a rather peculiar problem with My 1994 Dodge Grand Caravan 3.3L. This has happened multiple times spread out over the last 10 years. Every couple of years after a rather long drive, then a stop, it spits, sputters, has very little to no power, and will ultimately die. It will usually start right back up, idle fine, but when you shift into gear, it acts up as described. If you let it set for about 15-20 minutes, it will usually start up and run fine without the symptoms as described.
The First time it happened I was lucky enough to be within a mile of the dealer, who diagnosed a bad fuel pump before it was ever on the lift. He showed me what he said was the culprit, which was a fuel filter that was full of black particles and soot. He replaced both the pump and filter and it ran fine for a couple of years and it started doing the same thing. Another new fuel pump and filter and we're running again (all under warranty).
About three years ago it did it again and this time we went to a different dealer and since we were no longer under warranty, we wanted to know what was actually going wrong. Nothing was ever found, no codes, pressure was good, everything looked fine. No problems until today when it started again, no dash or check engine lights, it just wouldn't run. We let it sit for 20-30 minutes and started it right up and drove it home without incident.
Are these vehicles known for vapor locking? It sure acts like that is what it was doing. The temp wasn't that hot and was ruled out as a factor.
I am planning to put a new fuel filter in it?
Caravan/Voyager :: 2004 Dodge Lost Power To Windshield Washer Motor And Headlights
My 2004 Caravan lost power to windshield washer motor and headlights, after checking under fuse box, I swapped over the relay marked headlights washer , still nothing. I disconnected the power module at the front of the fuse box by removing four torx head screws. Removed it by rocking it a it out towards the front of the van. I cleaned the terminals and replaced it. Seems to have solved the problem .
View 1 Replies